A study of the three-dimensional stator-rotor interaction in a turbine stage is presented. Experimental data reveal vortices downstream of the rotor which are stationary in the absolute frame—indicating that they are caused by the stator exit flowfield. Evidence of the rotor hub passage vortices is seen, but additional vortical structures away from the endwalls, which would not be present if the rotor were tested in isolation, are also identified. An unsteady computation of the rotor row is performed using the measured stator exit flowfield as the inlet boundary condition. The strength and location of the vortices at rotor exit are predicted. A formation mechanism is proposed whereby stator wake fluid with steep spanwise gradients of absolute total pressure is responsible for all but one of the rotor exit vortices. This mechanism is then verified computationally using a passive-scalar tracking technique. The predicted loss generation through the rotor row is then presented and a comparison made with a steady calculation where the inlet flow has been mixed out to pitchwise uniformity. The loss produced in the steady simulation, even allowing for the mixing loss at inlet, is $10%$ less than that produced in the unsteady simulation. This difference highlights the importance of the time-accurate calculation as a tool of the turbomachine designer.

1.
Squire
,
H. B.
, and
Winter
,
K. G.
, 1951, “
The Secondary Flow in a Cascade of Airfoils in a Nonuniform Stream
,”
J. Aerosp. Sci.
0095-9820
18
, pp.
271
277
.
2.
Hawthorne
,
W. R.
, 1955, “
Rotational Flow Through Cascades, Part I: The Components of Vorticity
,”
J. Mech. and App. Math.
,
8
, pp.
266
279
.
3.
Smith
,
L. H.
, 1955, “
Secondary Flow in Axial-Flow Turbomachinery
,”
Trans. ASME
0097-6822
77
, p.
1065
.
4.
Denton
,
J.
, 1993, “
Loss Mechanisms in Turbomachines
,”
ASME J. Turbomach.
0889-504X,
115
, pp.
621
656
.
5.
Smith
,
L. H.
, 1966, “
Wake Dispersion in Turbomachines
,”
ASME J. Basic Eng.
0021-9223,
88
, pp.
688
690
.
6.
Valkov
,
T. V.
, and
Tan
,
C. S.
, 1999, “
Effect of Upstream Rotor Vortical Distribances on the Time-Averaged Performance of Axial Compressor Stators, Part I
,”
ASME J. Turbomach.
0889-504X,
121
, pp.
428
435
.
7.
Rose
,
M. G.
, and
Harvey
,
N. W.
, 2000, “
Turbomachinery Wakes: Differential Work and Mixing Losses
,”
ASME J. Turbomach.
0889-504X,
122
, pp.
68
77
.
8.
Pullan
,
G.
,
Denton
,
J. D.
, and
Dunkley
,
M. J.
, 2003, “
An Experimental and Computational Study of the Formation of a Streamwise Shed Vortex in a Turbine Stage
,”
ASME J. Turbomach.
0889-504X,
125
, pp.
291
297
.
9.
Koroumaru
,
M.
,
Inoue
,
M.
,
Higaki
,
T.
,
Abd-Elkhalek
,
F. A. E.
, and
Ikui
,
T.
, 1982, “
Measurement of Three-Dimensional Flow Field Behind and Impeller by means of Periodic Multisampling with a Slanted Hotwire
,” JSME,
25
.
10.
Goto
,
A.
, 1991, “
Three-Dimensional Flow and Mixing in an Axial Flow Compressor with Different Rotor Tip Clearances
,” ASME 91-GT-89.
11.
Pullan
,
G.
, and
Denton
,
J. D.
, 2003, “
Numerical Simulations of Vortex-Turbine Blade Interaction
,” 5th Euro. Conf. on Turbomachinery, Prague, pp.
1049
1059
.
12.
Denton
,
J. D.
, 1992, “
The Calculation of Three Dimensional Viscous Flow Through Multistage Turbomachines
,”
ASME J. Turbomach.
0889-504X,
114
, pp.
18
26
.
13.
He
,
L.
, and
Denton
,
J. D.
, 1994, “
3D Time Marching Inviscid and Viscous Solutions for Unsteady Flows around Vibrating Blades
,”
ASME J. Turbomach.
0889-504X,
116
, pp.
469
476
.
14.
Jameson
,
A.
, 1991, “
Time Dependent Calculations Using Multigrid, with Applications to Unsteady flows Past Airfoils and Wings
,” AIAA 91-1596.
15.
Denton
,
J. D.
, 2002, “
The Effects of Lean and Sweep on Transonic Fan Performance
,” TASK Quarterly Jan 2002, pp.
7
23
.
16.
Baldwin
,
B. S.
, and
Lomax
,
H.
, 1978, “
Thin Layer Approximation and Algebraic Model for Seperated Turbulent Flows
,” AIAA 78–257.
17.
Binder
,
R.
, and
Romey
,
A.
, 1983, “
Secondary Flow Effects and Mixing of the Wake Behind a Turbine Stator
,”
ASME J. Eng. Power
0022-0825,
105
, pp.
40
46
.
18.
Horlock
,
J. H.
, and
Lakshminarayana
,
B.
, 1973, “
Secondary Flows: Theory, Experiment, and Application in Turbomachinery Aerodynamics
,”
Annu. Rev. Fluid Mech.
0066-4189,
5
, pp.
247
249
.
19.
,
A.
, and
Beacher
,
B. F.
, 1990, “