A superposed radial outflow of air is used to cool two disks that are rotating at equal and opposite speeds at rotational Reynolds numbers up to 1.2 × 106. One disk, which is heated up to 100°C, is instrumented with thermocouples and fluxmeters; the other disk, which is unheated, is made from transparent polycarbonate to allow the measurement of velocity using an LDA system. Measured Nusselt numbers and velocities are compared with computations made using an axisymmetric elliptic solver with a low-Reynolds-number k–ε turbulence model. Over the range of flow rates and rotational speeds tested, agreement between the computations and measurements is mainly good. As suggested by the Reynolds analogy, the Nusselt numbers for contrarotating disks increase strongly with rotational speed and weakly with flow rate; they are lower than the values obtained under equivalent conditions in a rotor–stator system.

1.
Batchelor
G. K.
,
1951
, “
Note on a Class of Solutions of the Navier–Stokes Equations Representing Steady Rotationally-Symmetric Flow
,”
Quart. J. Mech. Appl. Math.
, Vol.
4
, pp.
29
41
.
2.
Chen, J.-X., Owen, J. M., and Wilson, M., 1993a, “Parallel-Computing Techniques Applied to Rotor-Stator Systems: Fluid Dynamics Computations,” Proc. 8th Intl. Conf. Numer. Meth. Laminar Turbulent Flow, Swansea, Pineridge Press, pp. 899–911.
3.
Chen, J.-X., and Owen, J. M., and Wilson, M., 1993b, “Parallel-Computing Techniques Applied to Rotor-Stator Systems: Thermal Computations,” Proc. 8th Intl. Conf. Numer. Meth. Thermal Problems, Swansea, Pineridge Press, pp. 1212–1226.
4.
Chen
J.-X.
,
Gan
X.
, and
Owen
J. M.
,
1996
, “
Heat Transfer in an Air-Cooled Rotor-Stator System
,”
ASME JOURNAL OF TURBOMACHINERY
, Vol.
118
, pp.
444
451
.
5.
Dorfman, L. A., 1963, Hydrodynamic Resistance and the Heat Loss of Rotating Solids, Oliver and Boyd, Edinburgh.
6.
Gan
X.
,
Kilic
M.
, and
Owen
J. M.
,
1995
, “
Flow Between Contrarotating Discs
,”
ASME JOURNAL OF TURBOMACHINERY
, Vol.
117
, pp.
298
305
.
7.
Graber, D. J., Daniels, W. A., and Johnson, B. V., 1987, “Disk Pumping Test,” Air Force Wright Aeronaut. Lab., Report No. AFWAL-TR-87-2050.
8.
Kilic
M.
,
Gan
X.
, and
Owen
J. M.
,
1994
a, “
Superposed Flow Between Two Discs Contrarotating at Differential Speeds
,”
Int. J. Heat Fluid Flow
, Vol.
15
, pp.
438
446
.
9.
Kilic
M.
,
Gan
X.
, and
Owen
J. M.
,
1994
b, “
Transitional Flow Between Contrarotating Discs
,”
J. Fluid Mech.
, Vol.
281
, pp.
119
135
.
10.
Kilic
M.
,
Gan
X.
, and
Owen
J. M.
,
1996
, “
Turbulent Flow Between Two Discs Contrarotating at Different Speeds
,”
ASME JOURNAL OF TURBOMACHINERY
, Vol.
118
, pp.
408
413
.
11.
Morse
A. P.
,
1988
, “
Numerical Prediction of Turbulent Flow in Rotating Cavities
,”
ASME JOURNAL OF TURBOMACHINERY
, Vol.
110
, pp.
202
215
.
12.
Morse
A. P.
,
1991
, “
Application of a Low Reynolds Number k–ε Turbulence Model to High-Speed Rotating Cavity Flows
,”
ASME JOURNAL OF TURBOMACHINERY
, Vol.
113
, pp.
98
105
.
13.
Owen, J. M., and Rogers, R. H., 1989, Flow and Heat Transfer in Rotating Disc Systems, Vol. 1: Rotor Stator Systems, Research Studies Press, Taunton (Wiley, New York).
14.
Stewartson
K.
,
1953
, “
On the Flow Between Two Rotating Coaxial Disks
,”
Proc. Camb. Phil. Soc.
, Vol.
49
, pp.
333
341
.
This content is only available via PDF.
You do not currently have access to this content.