The focus of this paper is an ultrasonic position indication system that is capable of determining one-dimensional target location in a high-temperature steel container with gaseous medium. The combination of the very high acoustical impedance of steel (45.4MRayl) and the very low impedance of a gas, for example, ambient air (0.0004MRayl), causes significant reflections at the interfaces. The strategy of this investigation was to develop an ultrasonic transducer capable of replacing a small portion of pressure vessel wall. In building such a transducer, acoustic matching layers for the steel-gas interface, a mechanically and acoustically competent housing, an efficient piezoelectric element, and appropriate backing materials are developed and tested. The results include a successful housing design, high- temperature acoustic matching layers, and subsequent successful wave forms with good signal-to-noise ratio. Target location through 9.6in.(24.5cm) of ambient air was possible, with a steel pressure boundary 0.456in.(1.160cm) thick, and the use of one matching layer. Our transducer was tested repeatedly to 340°C without apparent degradation. In addition to the experimental results, this investigation includes numerical simulations. Sample wave forms were predicted one dimensionally with the coupled acoustic piezoelectric analysis, a finite element program that predicts wave forms based on Navier’s equation for elastic wave propagation.

1.
Kinsler
,
L. E.
, and
Frey
,
A. R.
, 1962,
Fundamentals of Acoustics
,
2nd ed.
,
Wiley
,
New York
.
2.
Kino
,
G. S.
, 1987,
Acoustic Waves: Devices, Imaging, & Analog Signal Processing
,
Prentice-Hall, Inc.
,
Englewood Cliffs, NJ
.
3.
Grewe
,
M. G.
, 1989, “
Acoustic Matching and Backing Layers for Medical Ultrasonic Transducers
,” M.S. thesis, The Pennsylvania State University.
4.
Sandman
,
J. S.
, and
Tittmann
,
B. R.
, 2000, “
Development of an Air-Coupled Ultrasonic Sensor for High Pressure, and Temperature Applications
,”
Proc. SPIE
0277-786X,
3993
, pp.
214
227
.
5.
Auld
,
B. A.
, 1973,
Acoustic Fields and Waves in Solids
,
2nd ed.
,
K.
Malabar
, ed.,
Wiley
,
New York
, Vols.
1
and
2
.
6.
Mason
,
W. P.
, 1942,
Electromechanical Transducers and Wave Filters
,
Van Nostrand
,
Princeton, NJ
.
7.
Ewing
,
W. M.
,
Jardetzky
,
W. S.
, and
Press
,
F.
, 1957,
Elastic Waves in Layered Media
,
McGraw-Hill
,
New York
.
8.
Brekhovskikh
,
L. M.
, 1980,
Waves in Layered Media
,
Academic
,
New York
.
9.
Kaltenbacher
,
M.
, 2004,
Numerical Simulation of Mechatronic Sensors and Actuators
,
Springer-Verlag
,
Germany
.
10.
Hughes
,
T. J. R.
, 2000,
The Finite Element Method
,
Dover
,
New York
.
11.
Zienkiewicz
,
O. C.
, and
Taylor
,
R. L.
, 1998,
The Finite Element Method
,
McGraw-Hill
,
New York
.
12.
Allik
,
H.
, and
Hughes
,
T. J. R.
, 1970, “
Finite Element Method for Piezoelectric Vibration
,”
Int. J. Numer. Methods Eng.
0029-5981,
2
, pp.
151
157
.
13.
Lerch
,
R.
, 1990, “
Simulation of Piezoelectric Devices by Two- and Three-Dimensional Finite Elements
,”
IEEE Trans. Ultrason. Ferroelectr. Freq. Control
0885-3010,
37
(
3
), pp.
233
247
.
14.
Wojcik
,
G. L.
,
Vaughan
,
D. K.
,
Abboud
,
N.
, and
Mould
,
J.
, Jr.
, 1993, “
Electromechanical Modeling Using Explicit Time-Domain Finite Elements
,”
Proceedings of IEEE Ultrasonics Symposium
, pp.
1107
1112
.
15.
Van Crombrugge
,
M.
, 1983, “
Optimization of the Transmitting Characteristics of a Tonpilz-Type Transducer by Proper Choice of Impedance Matching Layers
,” M.S. thesis, The Pennsylvania State University.
16.
Gururaja
,
T. R.
, 1984, “
Piezoelectric Composite Materials for Ultrasonic Transducer Applications
,” Ph.D. thesis, The Pennsylvania State University.
17.
Dietz
,
F. T.
, 1951, “
Ultrasonic Absorption in Gases
,” Ph.D. thesis, The Pennsylvania State University.
18.
de Belleval
,
J. F.
, and
Lecuru
,
D.
, 1978, “
Improvement of Ultrasonic Transducers by Using Multilayer Front Face
,”
IEEE Ultrasonics Symposium Proceedings
, Vol.
SU1
, pp.
122
125
.
19.
Kossoff
,
G.
, 1966, “
The Effects of Backing and Matching on the Performance of Piezoelectric Ceramic Transducers
,”
IEEE Trans. Sonics Ultrason.
0018-9537,
SU-13
(
1
), pp.
20
30
.
You do not currently have access to this content.