Graphical Abstract Figure
Abstract
Offshore power cables are typically designed to have a service life of around 25 years. A pattern is emerging where these cables only last 10 years or even as little as two. The main consensus as to why the service life is so short is due to a combination of fatigue and fretting/wear damages of the copper conductors and water treeing in the insulation material. This study presents a method that can be used to analyze the structural integrity of dynamic subsea power cables and estimate their service life determined by the factors above. The numerical simulation models developed and used to carry out global and local fatigue analyses of dynamic subsea power cables are presented, together with methods and models for assessing fretting, wear, and growth of water tree defects. A methodology for structural integrity assessment that includes all these factors is proposed. A dynamic subsea power cable connected to a wave energy converter is used as the case study for comparison of the service life when these factors are considered compared to when, e.g., the growth of water trees is excluded. A numerical sensitivity analysis demonstrates that the value of the seawater's electrical conductivity and the insulation material's threshold stress-intensity factor greatly influence the cable's service life.
References
1.
O’Keeffe
, A.
, and Haggett
, C.
, 2012
, “An Investigation Into the Potential Barriers Facing the Development of Offshore Wind Energy in Scotland: Case Study–Firth of Forth Offshore Wind Farm
,” Renewable Sustainable Energy Rev.
, 16
(6
), pp. 3711
–3721
. 2.
GCube
, 2016
, Down to the Wire: An Insurance Buyer's Guide to Subsea Cabling Incidents. GCube Insurance Services, https://www.gcubeinsurance.com/reports/down-to-the-wire.3.
De Wild
, F.
, 2018
, “Offshore Wind Industry Joins Forces to Reduce Costs of Cable Failures,” https://www.dnv.com/news/offshore-wind-industry-joins-forces-to-reduce-costs-of-cable-failures-1178114.
Ech-Cheikh
, F.
, Matine
, A.
, and Drissi-Habti
, M.
, 2023
, “Preliminary Multiphysics Modeling of Electric High-Voltage Cable of Offshore Wind-Farms
,” Energies
, 16
(17
), p. 6286
. 5.
Hu
, H.
, Yan
, J.
, Sævik
, S.
, Ye
, N.
, Lu
, Q.
, and Bu
, Y.
, 2022
, “Nonlinear Bending Behavior of a Multilayer Copper Conductor in a Dynamic Power Cable
,” Ocean Eng.
, 250
, p. 110831
. 6.
Kuznecovs
, A.
, Ringsberg
, J. W.
, Yang
, S.-H.
, Johnson
, E.
, and Anderson
, A.
, 2019
, “A Methodology for Design and Fatigue Analysis of Power Cables for Wave Energy Converters
,” Int. J. Fatigue
, 122
, pp. 61
–71
. 7.
Sobhaniasl
, M.
, Petrini
, F.
, Karimirad
, M.
, and Bontempi
, F.
, 2020
, “Fatigue Life Assessment for Power Cables in Floating Offshore Wind Turbines
,” Energies
, 13
(12
), p. 3096
. 8.
Svensson
, G.
, Sævik
, S.
, and Ringsberg
, J. W.
, 2021
, “Fatigue Damage Analysis of Dynamic Power Cables by Laboratory Testing and FE Analysis
,” Developments in the Analysis and Design of Marine Structures—Proceedings of the Eighth International Conference on Marine Structures (MARSTRUCT 2021)
, Trondheim, Norway
, June 7–9
, CRC Press, Taylor & Francis Group
, pp. 477
–484
.9.
Thies
, P. R.
, Johanning
, L.
, and Smith
, G. H.
, 2011
, “Assessing Mechanical Loading Regimes and Fatigue Life of Marine Power Cables in Marine Energy Applications
,” Proc. Inst. Mech. Eng. Part O: J. Risk Reliab.
, 226
(1
), pp. 18
–32
. 10.
Wang
, W.
, Yan
, X.
, Li
, S.
, Zhang
, L.
, Ouyang
, J.
, and Ni
, X.
, 2021
, “Failure of Submarine Cables Used in High-Voltage Power Transmission: Characteristics, Mechanisms, Key Issues and Prospects
,” IET Gener., Transm. Distrib.
, 15
(9
), pp. 1387
–1402
. 11.
Young
, D. G.
, 2020
, “Predicting Failure of Dynamic Offshore Cables by Insulation Breakdown Due to Water Treeing
,” Ph.D. thesis
, University of Edinburgh
, UK
.12.
Li
, Z.
, Ringsberg
, J. W.
, Johnson
, E.
, and Serdyuk
, Y.
, 2022
, “Crack Propagation in Dynamic Power Cables
,” The ASME 2022 41st International Conference on Ocean, Offshore and Arctic Engineering (OMAE 2022)
, Hamburg, Germany
, June 5–10
, pp. 1
–8
.13.
Li
, Z.
, Ringsberg
, J. W.
, Serdyuk
, Y.
, Svensson
, D.
, Johnson
, E.
, and Andersson
, C.
, 2023
, “Predicting Failure of Dynamic Subsea Cables by Electrical Insulation Breakdown due to Water Treeing
,” Advances in the Analysis and Design of Marine Structures—Proceedings of the Ninth International Conference on Marine Structures (MARSTRUCT 2023)
, Gothenburg, Sweden
, Apr. 3–5
, CRC Press, Taylor & Francis Group
, pp. 477
–484
.14.
Ringsberg
, J. W.
, Kuznecovs
, A.
, Yang
, S.-H.
, and Johnson
, E.
, 2019
, “Models for Design and Fatigue Analysis of Dynamic Power Cables for Wave Energy Converters
,” Trends in the Analysis and Design of Marine Structures—Proceedings of the Seventh International Conference on Marine Structures (MARSTRUCT 2019)
, Dubrovnik, Croatia
, May 6–8
, CRC Press, Taylor & Francis Group
, pp. 488
–497
.15.
Ringsberg
, J. W.
, Yang
, S.-H.
, Lang
, X.
, Johnson
, E.
, and Kamf
, J.
, 2020
, “Mooring Forces in a Floating Point-Absorbing WEC System—A Comparison Between Full-Scale Measurements and Numerical Simulations
,” Ships Offshore Struct.
, 15
(suppl. 1
), pp. S70
–S81
. 16.
Yang
, S.-H.
, Ringsberg
, J. W.
, and Johnson
, E.
, 2018
, “Parametric Study of the Dynamic Motions and Mechanical Characteristics of Power Cables for Wave Energy Converters
,” J. Mar. Sci. Technol.
, 23
(1
), pp. 10
–29
. 17.
Yang
, S.-H.
, Ringsberg
, J. W.
, Johnson
, E.
, and Hu
, Z.
, 2021
, “Experimental and Numerical Investigation of a Taut-Moored Wave Energy Converter: A Validation of Simulated Mooring Line Forces
,” Ships Offshore Struct.
, 15
(suppl. 1
), pp. S55
–S69
. 18.
Ringsberg
, J. W.
, Dieng
, L.
, Li
, Z.
, and Hagman
, I.
, 2023
, “Characterization of the Mechanical Properties of Low Stiffness Marine Power Cables Through Tension, Bending, Torsion, and Fatigue Testing
,” J. Mar. Sci. Eng.
, 11
(9
), pp. 1
–19
. 19.
Johannesson
, P.
, Lang
, X.
, Johnson
, E.
, and Ringsberg
, J. W.
, 2022
, “Mechanical Reliability Analysis of Flexible Power Cables for Marine Energy
,” J. Mar. Sci. Eng.
, 10
(6
), pp. 1
–19
. 20.
Faremo
, H.
, Benjaminsen
, J.
, Larsen
, P.
, and Tunheim
, A.
, 1997
, “Service Experience for XLPE Cables Installed in Norway—From Graphite Painted Insulation Screens to Axially and Radially Water Tight Cable Constructions
,” Proceedings of the 14th International Conference and Exhibition on Electricity Distribution
, Birmingham, UK
, June 2–5
, pp. 592
–595
.21.
Hellesø
, S.
, Benjaminsen
, J. T.
, Selsjord
, M.
, and Hvidsten
, S.
, 2012
, “Water Tree Initiation and Growth in XLPE Cables Under Static and Dynamic Mechanical Stress
,” Proceedings of 2012 IEEE International Symposium on Electrical Insulation
, San Juan, Puerto Rico, USA
, June 10–13
, pp. 623
–627
. 22.
Hvidsten
, S.
, Ildstad
, E.
, Sletbak
, J.
, and Faremo
, H.
, 1998
, “Understanding Water Treeing Mechanisms in the Development of Diagnostic Test Methods
,” IEEE Trans. Dielectr. Electr. Insul.
, 5
(5
), pp. 754
–760
. 23.
Det Norske Veritas (DNV)
, 2021
, SESAM User Manual SIMA: Version 4.1
, Det Norske Veritas
, Høvik, Norway
.24.
Dowling
, N. E.
, 2007
, Mechanical Behavior of Materials: Engineering Methods for Deformation, Fracture, and Fatigue
, 3rd ed., Pearson
.25.
26.
Ding
, G.
, Karlsson
, A. M.
, and Santare
, M. H.
, 2017
, “Numerical Evaluation of Fatigue Crack Growth in Polymers Based on Plastically Dissipated Energy
,” Int. J. Fatigue
, 94
(Part 1
), pp. 89
–96
. 27.
COMSOL
, 2020
, COMSOL Multiphysics Reference Manual (Version 5.5).28.
Archard
, J. F.
, 1953
, “Contact and Rubbing of Flat Surfaces
,” J. Appl. Phys.
, 24
(8
), pp. 981
–988
. 29.
McColl
, I. R.
, Ding
, J.
, and Leen
S.B.
, 2004
, “Finite Element Simulation and Experimental Validation of Fretting Wear
,” Wear
, 256
(11–12
), pp. 1114
–1127
. 30.
31.
Ringsberg
, J. W.
, 2021
, “Life Prediction of Rolling Contact Fatigue Crack Initiation
,” Int. J. Fatigue
, 23
(7
), pp. 575
–586
. 32.
Tao
, W.
, Ma
, Z.
, Wang
, W.
, Liu
, J.
, Zhou
, K.
, Li
, T.
, and Huang
, M.
, 2016
, “The Mechanism of Water Tree Growth in XLPE Cables Based on the Finite Element Method
,” 2016 IEEE International Conference on High Voltage Engineering and Application (ICHVE)
, Chengdu, China, Sept. 19–22
, pp. 1
–4
. 33.
Fagan
, N.
, McCormick
, R.
, Marwood
, T.
, and Stewart
, G.
, 2024
, “Structural Integrity Analysis of Marine Dynamic Cables
”, Technical Report 2024:01, Department of Mechanics and Maritime Sciences, Division of Marine Technology, Chalmers University of Technology
, Gothenburg, Sweden
, https://research.chalmers.se/en/publication/?id=540406
