Abstract

This paper begins with a numerical study based on earlier experiments of nonlinear vibro-ultrasonic behavior of a composite laminate with a delamination defect upon sinusoidal linear sweep signal excitation. A methodology to model laminates with cross-ply layup is presented which can be extended to any layup if desired. In comparison to experiments where it is challenging to visualize the fine details of vibrations, simulations make it easier to visualize and help in optimizing the defect probing methods. The paper goes on to discuss with the help of numerical results that a separation gap between the delamination surfaces occurs to be a common cause for the failure of nonlinear vibro-ultrasonic methods to detect delamination defects. This constraint can often be overcome with application of higher excitation amplitudes as has been demonstrated in several experimental works. However, in this study, a new approach named surface vibration comparison method to probe delamination defects in the absence of contact acoustic nonlinearity is proposed as a proof-of-concept. The technique is then evaluated for detection of weak kissing bond defects in composite beam specimens. Both the experimental and simulation results show potential of the method as damage detection technique in thin composite structures.

References

1.
Rose
,
J. L.
,
2014
,
Ultrasonic Guided Waves in Solid Media
,
Cambridge University Press
,
Cambridge, UK
.
2.
Su
,
Z.
, and
Ye
,
L.
,
2009
,
Identification of Damage Using Lamb Waves: From Fundamentals to Applications
, Vol.
48
,
Springer Science & Business Media
,
Berlin, Germany
.
3.
Stepinski
,
T.
,
Uhl
,
T.
, and
Staszewski
,
W.
,
2013
,
Nonlinear Acoustics
,
John Wiley & Sons
,
Hoboken, NJ
, pp.
73
107
(book section 4).
4.
Broda
,
D.
,
Staszewski
,
W. J.
,
Martowicz
,
A.
,
Uhl
,
T.
, and
Silberschmidt
,
V. V.
,
2014
, “
Modelling of Nonlinear Crack-Wave Interactions for Damage Detection Based on Ultrasound—A Review
,”
J. Sound Vib.
,
333
(
4
), pp.
1097
1118
.
5.
Bovsunovsky
,
A.
, and
Surace
,
C.
,
2015
, “
Non-linearities in the Vibrations of Elastic Structures With a Closing Crack: A State of the Art Review
,”
Mech. Syst. Signal Process.
,
62–63
, pp.
129
148
.
6.
Pieczonka
,
L.
,
Klepka
,
A.
,
Martowicz
,
A.
, and
Staszewski
,
W. J.
,
2016
, “
Nonlinear Vibroacoustic Wave Modulations for Structural Damage Detection: An Overview
,”
Opt. Eng.
,
55
(
1
), p.
011005
.
7.
Fierro
,
G. P. M.
, and
Meo
,
M.
,
2018
, “
Nonlinear Elastic Imaging of Barely Visible Impact Damage in Composite Structures Using a Constructive Nonlinear Array Sweep Technique
,”
Ultrasonics
,
90
, pp.
125
143
.
8.
Klepka
,
A.
,
Pieczonka
,
L.
,
Staszewski
,
W.
, and
Aymerich
,
F.
,
2014
, “
Impact Damage Detection in Laminated Composites by Non-linear Vibro-acoustic Wave Modulations
,”
Compos. Part B: Eng.
,
65
, pp.
99
108
.
9.
Polimeno
,
U.
,
Meo
,
M.
,
Almond
,
D.
, and
Angioni
,
S.
,
2010
, “
Detecting Low Velocity Impact Damage in Composite Plate Using Nonlinear Acoustic/Ultrasound Methods
,”
Appl. Compos. Mater.
,
17
(
5
), pp.
481
488
.
10.
Delrue
,
S.
, and
Van Den Abeele
,
K.
,
2012
, “
Three-Dimensional Finite Element Simulation of Closed Delaminations in Composite Materials
,”
Ultrasonics
,
52
(
2
), pp.
315
324
.
11.
Singh
,
A. K.
,
Chen
,
B. Y.
,
Tan
,
V. B. C.
,
Tay
,
T. E.
, and
Lee
,
H. P.
,
2017
, “
Finite Element Modeling of Nonlinear Acoustics/Ultrasonics for the Detection of Closed Delaminations in Composites
,”
Ultrasonics
,
74
, pp.
89
98
.
12.
Sarens
,
B.
,
Verstraeten
,
B.
,
Glorieux
,
C.
,
Kalogiannakis
,
G.
, and
Van Hemelrijck
,
D.
,
2010
, “
Investigation of Contact Acoustic Nonlinearity in Delaminations by Shearographic Imaging, Laser Doppler Vibrometric Scanning and Finite Difference Modeling
,”
IEEE Trans. Ultrason. Ferroelectr. Freq. Control
,
57
(
6
), pp.
1383
1395
.
13.
Delrue
,
S.
,
Aleshin
,
V.
,
Truyaert
,
K.
,
Matar
,
O. B.
, and
Van Den Abeele
,
K.
,
2018
, “
Two Dimensional Modeling of Elastic Wave Propagation in Solids Containing Cracks With Rough Surfaces and Friction—Part Ii: Numerical Implementation
,”
Ultrasonics
,
82
, pp.
19
30
.
14.
Biwa
,
S.
, and
Ishii
,
Y.
,
2016
, “
Second-Harmonic Generation in an Infinite Layered Structure With Nonlinear Spring-Type Interfaces
,”
Wave Motion
,
63
, pp.
55
67
.
15.
Delrue
,
S.
,
Tabatabaeipour
,
M.
,
Hettler
,
J.
, and
Van Den Abeele
,
K.
,
2016
, “
Applying a Nonlinear, Pitch-Catch, Ultrasonic Technique for the Detection of Kissing Bonds in Friction Stir Welds
,”
Ultrasonics
,
68
, pp.
71
79
.
16.
Yuan
,
M.
,
Lee
,
T.
,
Kang
,
T.
,
Zhang
,
J.
,
Song
,
S.-J.
, and
Kim
,
H.-J.
,
2015
, “
Absolute Measurement of Ultrasonic Non-linearity Parameter at Contact Interface
,”
Nondestruct. Test. Eval.
,
30
(
4
), pp.
356
372
.
17.
Garcia
,
D.
,
Palazzetti
,
R.
,
Trendafilova
,
I.
,
Fiorini
,
C.
, and
Zucchelli
,
A.
,
2015
, “
Vibration-Based Delamination Diagnosis and Modelling for Composite Laminate Plates
,”
Compos. Struct.
,
130
, pp.
155
162
.
18.
Burlayenko
,
V.
, and
Sadowski
,
T.
,
2012
, “
Finite Element Nonlinear Dynamic Analysis of Sandwich Plates With Partially Detached Facesheet and Core
,”
Finite Elements Anal. Des.
,
62
, pp.
49
64
.
19.
Singh
,
A. K.
,
Tan
,
V. B. C.
,
Tay
,
T. E.
, and
Lee
,
H. P.
,
2019
, “
Experimental Investigations Into Nonlinear Vibro-acoustics for Detection of Delaminations in a Composite Laminate
,”
J. Nondestruct. Eval. Diag. Prog. Eng. Syst.
,
2
(
1
), p.
011002
.
20.
Solodov
,
I.
,
Bai
,
J.
,
Bekgulyan
,
S.
, and
Busse
,
G.
,
2011
, “
A Local Defect Resonance to Enhance Acoustic Wave-Defect Interaction in Ultrasonic Nondestructive Evaluation
,”
Appl. Phys. Lett.
,
99
(
21
), p.
211911
.
21.
Solodov
,
I.
,
Bai
,
J.
,
Bekgulyan
,
S.
, and
Busse
,
G.
,
2012
, “
A Local Defect Resonance to Enhance Wave-Defect Interaction in Nonlinear Spectroscopy and Ultrasonic Thermography
,”
18th World Conference on Nondestructive Testing
,
Durban, South Africa
,
Apr. 16–20
, pp.
16
20
.
22.
Rahammer
,
M.
, and
Kreutzbruck
,
M.
,
2017
, “
Fourier-Transform Vibrothermography With Frequency Sweep Excitation Utilizing Local Defect Resonances
,”
NDT & E Int.
,
86
, pp.
83
88
.
23.
Delrue
,
S.
, and
Van Den Abeele
,
K.
,
2015
, “
A Simulation Study of Local Defect Resonances (LDR)
,”
6th International Conference on Emerging Technologies in Non-Destructive Testing
,
Belgium, Brussels
,
May 27–29
, CRC Press, p.
167
.
24.
Delrue
,
S.
,
Tabatabaeipour
,
M.
,
Hettler
,
J.
, and
van Den Abeele
,
K.
,
2015
, “
Non-destructive Evaluation of Kissing Bonds Using Local Defect Resonance (LDR) Spectroscopy: A Simulation Study
,”
Phys. Procedia
,
70
, pp.
648
651
.
25.
Shelke
,
A.
,
Kundu
,
T.
,
Amjad
,
U.
,
Hahn
,
K.
, and
Grill
,
W.
,
2011
, “
Mode-Selective Excitation and Detection of Ultrasonic Guided Waves for Delamination Detection in Laminated Aluminum Plates
,”
IEEE Trans. Ultrason. Ferroelectr. Freq. Control
,
58
(
3
), pp.
567
577
.
26.
Shang
,
J.
,
Ngern
,
N. H.
, and
Tan
,
V. B.
,
2016
, “
Crustacean-Inspired Helicoidal Laminates
,”
Compos. Sci. Technol.
,
128
, pp.
222
232
.
27.
Physik Instrumente (PI) GmbH, 2018, “PI Piezoelectric Discs Datasheet,” Karlsruhe, Germany.
28.
Wang
,
T. W.
, and
Yang
,
C. H.
,
2014
, “
Effective Models of PZT Actuators for Numerical Simulation of Elastic Wave Propagation
,”
Appl. Mech. Mater.
,
553
, pp.
705
710
.
29.
Wang
,
T.
,
2014
, “
Finite Element Modelling and Simulation of Guided Wave Propagation in Steel Structural Members
,” Thesis, University of Western Sydney, Sydney, Australia.
30.
Giurgiutiu
,
V.
,
2007
,
Structural Health Monitoring: With Piezoelectric Wafer Active Sensors
,
Academic Press
,
Cambridge, MA
.
31.
Singh
,
A.
,
Tan
,
V.
,
Tay
,
T.
, and
Lee
,
H.
,
2016
, “
A Novel Nonlinear Acoustics Technique for the Detection of Defects in Composite Laminates
,”
Eighth International Symposium on NDT in Aerospace
,
Bangalore, India
,
Nov. 3–5
pp.
3
5
.
32.
Krohn
,
N.
,
Stoessel
,
R.
, and
Busse
,
G.
,
2002
, “
Acoustic Non-linearity for Defect Selective Imaging
,”
Ultrasonics
,
40
(
1
), pp.
633
637
.
33.
Solodov
,
I.
,
Wackerl
,
J.
,
Pfleiderer
,
K.
, and
Busse
,
G.
,
2004
, “
Nonlinear Self-modulation and Subharmonic Acoustic Spectroscopyfor Damage Detection and Location
,”
Appl. Phys. Lett.
,
84
(
26
), pp.
5386
5388
.
34.
Kawashima
,
K.
,
Murase
,
M.
,
Yamada
,
R.
,
Matsushima
,
M.
,
Uematsu
,
M.
, and
Fujita
,
F.
,
2006
, “
Nonlinear Ultrasonic Imaging of Imperfectly Bonded Interfaces
,”
Ultrasonics
,
44
, pp.
e1329
e1333
.
35.
Solodov
,
I.
,
Döring
,
D.
, and
Busse
,
G.
,
2011
, “
New Opportunities for NDT Using Non-linear Interaction of Elastic Waves With Defects
,”
Strojniški vestnik-J. Mech. Eng.
,
57
(
3
), pp.
169
182
.
36.
Dionysopoulos
,
D.
,
Fierro
,
G.-P. M.
,
Meo
,
M.
, and
Ciampa
,
F.
,
2018
, “
Imaging of Barely Visible Impact Damage on a Composite Panel Using Nonlinear Wave Modulation Thermography
,”
NDT & E Int.
,
95
, pp.
9
16
.
37.
Cao
,
M.
,
Su
,
Z.
,
Deng
,
T.
, and
Xu
,
W.
,
2021
, “
Nonlinear Pseudo-force in “Breathing” Delamination to Generate Harmonics: A Mechanism and Application Study
,”
Int. J. Mech. Sci.
,
192
, p.
106124
.
38.
Meo
,
M.
, and
Zumpano
,
G.
,
2005
, “
Nonlinear Elastic Wave Spectroscopy Identification of Impact Damage on a Sandwich Plate
,”
Compos. Struct.
,
71
(
3
), pp.
469
474
.
39.
Chen
,
B. Y.
,
Soh
,
S. K.
,
Lee
,
H. P.
,
Tay
,
T. E.
, and
Tan
,
V. B. C.
,
2016
, “
A Vibro-acoustic Modulation Method for the Detection of Delamination and Kissing Bond in Composites
,”
J. Compos. Mater.
,
50
(
22
), pp.
3089
3104
.
40.
Solodov
,
I. Y.
,
Krohn
,
N.
, and
Busse
,
G.
,
2002
, “
Can: An Example of Nonclassical Acoustic Nonlinearity in Solids
,”
Ultrasonics
,
40
(
1
), pp.
621
625
.
41.
Duffour
,
P.
,
Morbidini
,
M.
, and
Cawley
,
P.
,
2006
, “
A Study of the Vibro-acoustic Modulation Technique for the Detection of Cracks in Metals
,”
J. Acoust. Soc. Am.
,
119
(
3
), pp.
1463
1475
.
42.
Duffour
,
P.
,
Morbidini
,
M.
, and
Cawley
,
P.
,
2006
, “
Comparison Between a Type of Vibro-acoustic Modulation and Damping Measurement as NDT Techniques
,”
NDT & E Int.
,
39
(
2
), pp.
123
131
.
43.
Ohara
,
Y.
,
Mihara
,
T.
, and
Yamanaka
,
K.
,
2006
, “
Effect of Adhesion Force Between Crack Planes on Subharmonic and DC Responses in Nonlinear Ultrasound
,”
Ultrasonics
,
44
(
2
), pp.
194
199
.
44.
Parsons
,
Z.
, and
Staszewski
,
W.
,
2006
, “
Nonlinear Acoustics With Low-Profile Piezoceramic Excitation for Crack Detection in Metallic Structures
,”
Smart Mater. Struct.
,
15
(
4
), p.
1110
.
45.
Zaitsev
,
V.
,
Nazarov
,
V.
,
Gusev
,
V.
, and
Castagnede
,
B.
,
2006
, “
Novel Nonlinear-Modulation Acoustic Technique for Crack Detection
,”
NDT & E Int.
,
39
(
3
), pp.
184
194
.
46.
Solodov
,
I.
,
Krohn
,
N.
, and
Busse
,
G.
,
2010
, “
Nonlinear Ultrasonic NDT for Early Defect Recognition and Imaging
,”
European Conference on NDT (ECNDT)
,
Moscow, Citeseer
,
June 7–11
.
47.
Delrue
,
S.
, and
Van Den Abeele
,
K.
,
2015
, “
Detection of Defect Parameters Using Nonlinear Air-Coupled Emission by Ultrasonic Guided Waves at Contact Acoustic Nonlinearities
,”
Ultrasonics
,
63
, pp.
147
154
.
48.
Lingvall
,
F.
, and
Skoglund
,
E.
,
2015
, “DolphiCam 1.3 Technical Paper.”
49.
Yan
,
D.
,
Drinkwater
,
B. W.
, and
Neild
,
S. A.
,
2009
, “
Measurement of the Ultrasonic Nonlinearity of Kissing Bonds in Adhesive Joints
,”
NDT & E Int.
,
42
(
5
), pp.
459
466
.
50.
Brotherhood
,
C.
,
Drinkwater
,
B.
, and
Dixon
,
S.
,
2003
, “
The Detectability of Kissing Bonds in Adhesive Joints Using Ultrasonic Techniques
,”
Ultrasonics
,
41
(
7
), pp.
521
529
.
51.
Rothenfusser
,
M.
,
Mayr
,
M.
, and
Baumann
,
J.
,
2000
, “
Acoustic Nonlinearities in Adhesive Joints
,”
Ultrasonics
,
38
(
1
), pp.
322
326
.
52.
Brotherhood
,
C.
,
Drinkwater
,
B.
, and
Guild
,
F.
,
2002
, “
The Effect of Compressive Loading on the Ultrasonic Detectability of Kissing Bonds in Adhesive Joints
,”
J. Nondestruct. Eval.
,
21
(
3
), pp.
95
104
.
53.
Nagy
,
P. B.
,
1991
, “
Ultrasonic Detection of Kissing Bonds at Adhesive Interfaces
,”
J. Adhes. Sci. Technol.
,
5
(
8
), pp.
619
630
.
54.
Kundu
,
T.
,
Maji
,
A.
,
Ghosh
,
T.
, and
Maslov
,
K.
,
1998
, “
Detection of Kissing Bonds by Lamb Waves
,”
Ultrasonics
,
35
(
8
), pp.
573
580
.
55.
Wood
,
M.
,
Charlton
,
P.
, and
Yan
,
D.
,
2014
, “
Ultrasonic Evaluation of Artificial Kissing Bonds in CFRP Composites
,”
e-J. NDT
,
19
(
12
), pp.
1
0
.
56.
Ikeda
,
T.
,
1996
,
Fundamentals of Piezoelectricity
,
Oxford University Press
,
Oxford, UK
.
57.
Abaqus Documentation,
2017
, Version 2017, Dassault Systémes Simulia Corp., Providence, RI.
58.
Singh
,
A. K.
,
Chen
,
B. Y.
,
Tan
,
V. B. C.
,
Tay
,
T. E.
, and
Lee
,
H. P.
,
2017
, “
A Theoretical and Numerical Study on the Mechanics of Vibro-acoustic Modulation
,”
J. Acoust. Soc. Am.
,
141
(
4
), pp.
2821
2831
.
You do not currently have access to this content.