Abstract
Studies have shown that the suspended backpack, a wearable device allowing the backpack moving relative to user’s back, can effectively reduce the accelerative vertical force of the backpack to reduce the metabolic cost of users. However, the existing suspended backpack cannot eliminate the accelerative vertical force due to the nonzero suspension stiffness. This paper proposes a constant force suspended backpack adaptable to the varying load to eliminate the accelerative vertical force on the load. To this end, a spring constant force balancing mechanism is designed to achieve near-zero-stiffness suspension. Moreover, a multi-pulley compensation mechanism is proposed for compensating the balance error caused by the pulley diameter to achieve constant force theoretically, and an adjustable mechanism is added to the suspended backpack to nearly achieve constant force balance under different loads. We conducted experiments to validate the efficiency of the constant force suspended backpack. The results demonstrate that the suspended backpack can effectively reduce the maximum net metabolic power of the human by 13.1%, the displacement of the load is reduced by 87.5%, and the peak average acceleration vertical force reduction rate is 88.5%.
Issue Section:
Research Papers
References
1.
Park
, S.
, and Jayaraman
, S.
, 2003
, “Enhancing the Quality of Life Through Wearable Technology
,” IEEE Eng. Med. Biol. Mag.
, 22
(3
), pp. 41
–48
. 2.
Knapik
, J.
, Harman
, E.
, and Reynolds
, K.
, 1996
, “Load Carriage Using Packs: A Review of Physiological, Biomechanical and Medical Aspects
,” Appl. Ergon.
, 27
(3
), pp. 207
–216
. 3.
Park
, J.-H.
, Stegall
, P.
, and Agrawal
, S. K.
, 2016
, “Reducing Dynamic Loads From a Backpack During Load Carriage Using an Upper Body Assistive Device
,” ASME J. Mech. Rob.
, 8
(5
), p. 051017
. 4.
Hong
, Y.
, Li
, J.-X.
, and Fong
, D. T.-P.
, 2008
, “Effect of Prolonged Walking With Backpack Loads on Trunk Muscle Activity and Fatigue in Children
,” J. Electromyogr. Kinesiology
, 18
(6
), pp. 990
–996
. 5.
Bastien
, G. J.
, Willems
, P. A.
, Schepens
, B.
, and Heglund
, N. C.
, 2005
, “Effect of Load and Speed on the Energetic Cost of Human Walking
,” Eur. J. Appl. Physiol.
, 94
(1–2
), pp. 76
–83
. 6.
Simpson
, K. M.
, Munro
, B. J.
, and Steele
, J. R.
, 2011
, “Backpack Load Affects Lower Limb Muscle Activity Patterns of Female Hikers During Prolonged Load Carriage
,” J. Electromyogr. Kinesiology
, 21
(5
), pp. 782
–788
. 7.
Hong
, Y.
, and Cheung
, C.-K.
, 2003
, “Gait and Posture Responses to Backpack Load During Level Walking in Children
,” Gait & Posture
, 17
(1
), pp. 28
–33
.8.
Attwells
, R. L.
, Birrell
, S. A.
, Hooper
, R. H.
, and Mansfield
, N. J.
, 2006
, “Influence of Carrying Heavy Loads on Soldiers’ Posture, Movements and Gait
,” Ergonomics
, 49
(14
), pp. 1527
–1537
. 9.
Hadid
, A.
, Belzer
, N.
, Shabshin
, N.
, Zeilig
, G.
, Gefen
, A.
, and Epstein
, Y.
, 2015
, “The Effect of Mechanical Strains in Soft Tissues of the Shoulder During Load Carriage
,” J. Biomech.
, 48
(15
), pp. 4160
–4165
. 10.
Abe
, D.
, Muraki
, S.
, and Yasukouchi
, A.
, 2008
, “Ergonomic Effects of Load Carriage on Energy Cost of Gradient Walking
,” Appl. Ergon.
, 39
(2
), pp. 144
–149
. 11.
Birrell
, S. A.
, and Haslam
, R. A.
, 2009
, “The Effect of Military Load Carriage on 3-D Lower Limb Kinematics and Spatiotemporal Parameters
,” Ergonomics
, 52
(10
), pp. 1298
–1304
. .12.
Birrell
, S. A.
, and Haslam
, R. A.
, 2010
, “The Effect of Load Distribution within Military Load Carriage Systems on the Kinetics of Human Gait
,” Appl. Ergon.
, 41
(4
), pp. 585
–590
. 13.
Maloiy
, G. M. O.
, Heglund
, N. C.
, Prager
, L. M.
, Cavagna
, G. A.
, and Taylor
, C. R.
, 1986
, “Energetic Cost of Carrying Loads: Have African Women Discovered an Economic Way?
,” Nature
, 319
(6055
), pp. 668
–669
.14.
Bastien
, G. J.
, Schepens
, B.
, Willems
, P. A.
, and Heglund
, N. C.
, 2005
, “Energetics of Load Carrying in Nepalese Porters
,” Science
, 308
(5729
), pp. 1755
–1755
.15.
Zhang
, B.
, Liu
, Y.
, Fan
, W.
, Wang
, Z.
, and Liu
, T.
, 2020
, “Pilot Study of a Hover Backpack With Tunable Air Damper for Decoupling Load and Human
,” 2020 IEEE/ASME International Conference on Advanced Intelligent Mechatronics (AIM)
, Boston, MA
, July 6–9
, pp. 1834–1839
.16.
Kram
, R.
, 1991
, “Carrying Loads With Springy Poles
,” J. Appl. Physiol.
, 71
(3
), pp. 1119
–1122
. 17.
Castillo
, E. R.
, Lieberman
, G. M.
, McCarty
, L. S.
, and Lieberman
, D. E.
, 2014
, “Effects of Pole Compliance and Step Frequency on the Biomechanics and Economy of Pole Carrying During Human Walking
,” J. Appl. Physiol.
, 117
(5
), pp. 507
–517
. 18.
Schroeder
, R. T.
, Croft
, J. L.
, Ngo
, G. D.
, and Bertram
, J. E. A.
, 2018
, “Properties of Traditional Bamboo Carrying Poles Have Implications for User Interactions
,” PLoS ONE
, 13
(5
), p. e0196208
.19.
Potwar
, K.
, Ackerman
, J.
, and Seipel
, J.
, 2015
, “Design of Compliant Bamboo Poles for Carrying Loads
,” ASME J. Mech. Des.
, 137
(1
), p. 011404
. 20.
Keren
, R.
, and Or
, Y.
, 2018
, “Theoretical Analysis and Numerical Optimization of a Wearable Spring-Clutch Mechanism for Reducing Metabolic Energy Cost During Human Walking
,” ASME J. Mech. Rob.
, 10
(6
), p. 061004
. 21.
Hao
, M.
, Zhang
, J.
, Chen
, K.
, Asada
, H.
, and Fu
, C.
, 2020
, “Supernumerary Robotic Limbs to Assist Human Walking With Load Carriage
,” ASME J. Mech. Rob.
, 12
(6
), p. 061014
. 22.
Kim
, W. S.
, Lee
, H. D.
, Lim
, D. H.
, Han
, C. S.
, and Han
, J. S.
, 2013
, “Development of a Lower Extremity Exoskeleton System for Walking Assistance While Load Carrying
,” Proceedings of the Sixteenth International Conference on Climbing and Walking Robots
, Sydney, Australia
, July 14–17
, pp. 35
–42
.23.
Wang
, S.
, Wang
, L.
, Meijneke
, C.
, van Asseldonk
, E.
, Hoellinger
, T.
, Cheron
, G.
, Ivanenko
, Y.
, et al, 2015
, “Design and Control of the Mindwalker Exoskeleton
,” IEEE Trans. Neural Syst. Rehabil. Eng.
, 23
(2
), pp. 277
–286
.24.
Zoss
, A. B.
, Kazerooni
, H.
, and Chu
, A.
, 2006
, “Biomechanical Design of the Berkeley Lower Extremity Exoskeleton (BLEEX)
,” IEEE/ASME Trans. Mechatron.
, 11
(2
), pp. 128
–138
.25.
Rome
, L.
, Flynn
, L.
, and Yoo
, T.
, 2006
, “Biomechanics: Rubber Bands Reduce 662 the Cost of Carrying Loads
,” Nature
, 444
(7122
), pp. 1023
–1024
.26.
Rome
, L. C.
, Flynn
, L.
, Goldman
, E. M.
, and Yoo
, T. D.
, 2005
, “Generating Electricity While Walking With Loads
,” Science
, 309
(5741
), pp. 1725
–1728
.27.
Ackerman
, J.
, and Seipel
, J.
, 2014
, “A Model of Human Walking Energetics With an Elastically-Suspended Load
,” J. Biomech.
, 47
(8
), pp. 1922
–1927
. 28.
Foissac
, M.
, Millet
, G. Y.
, Geyssant
, A.
, Freychat
, P.
, and Belli
, A.
, 2009
, “Characterization of the Mechanical Properties of Backpacks and Their Influence on the Energetics of Walking
,” J. Biomech.
, 42
(2
), pp. 125
–130
. .29.
Xie
, L.
, and Cai
, M.
, 2015
, “Development of a Suspended Backpack for Harvesting Biomechanical Energy
,” ASME J. Mech. Des.
, 137
(5
), p. 054503
. 30.
Xie
, L.
, and Cai
, M.
, 2015
, “Increased Energy Harvesting and Reduced Accelerative Load for Backpacks via Frequency Tuning
,” Mech. Syst. Signal Process.
, 58–59
, pp. 399
–415
.31.
He
, L.
, Xiong
, C.
, Zhang
, Q.
, Chen
, W.
, Fu
, C.
, and Lee
, K.-M.
, 2020
, “A Backpack Minimizing the Vertical Acceleration of the Load Improves the Economy of Human Walking
,” IEEE Trans. Neural Syst. Rehabil. Eng.
, 28
(9
), pp. 1994
–2004
.32.
Yang
, L.
, Zhang
, J.
, Xu
, Y.
, Chen
, K.
, and Fu
, C.
, 2020
, “Energy Performance Analysis of a Suspended Backpack With an Optimally Controlled Variable Damper for Human Load Carriage
,” Mech. Mach. Theory
, 146
, p. 103738
. 33.
Shaw
, J.-S.
, and Wang
, C.-A.
, 2019
, “Design and Control of Adaptive Vibration Absorber for Multimode Structure
,” J. Intell. Mater. Syst. Struct.
, 30
(7
), pp. 1043
–1052
.34.
Li
, H.
, Li
, Y.
, and Li
, J.
, 2020
, “Negative Stiffness Devices for Vibration Isolation Applications: A Review
,” Adv. Struct. Eng.
, 23
(8
), pp. 1739
–1755
. 35.
Zhou
, J.
, Wang
, X.
, Xu
, D.
, and Bishop
, S.
, 2015
, “Nonlinear Dynamic Characteristics of a Quasi-Zero Stiffness Vibration Isolator With Cam–Roller–Spring Mechanisms
,” J. Sound Vib.
, 346
, pp. 53
–69
. 36.
Zou
, W.
, Cheng
, C.
, Ma
, R.
, Hu
, Y.
, and Wang
, W.
, 2021
, “Performance Analysis of a Quasi-zero Stiffness Vibration Isolation System With Scissor-Like Structures
,” Arch. Appl. Mech.
, 91
(1
), pp. 117
–133
.37.
Hoover
, J.
, and Meguid
, S. A.
, 2011
, “Performance Assessment of the Suspended-Load Backpack
,” Int. J. Mech. Mater. Des.
, 7
(2
), pp. 111
–121
. 38.
Leng
, Y.
, Lin
, X.
, Lu
, Z.
, Song
, A.
, Yu
, Z.
, and Fu
, C.
, 2020
, “A Model to Predict Ground Reaction Force for Elastically-Suspended Backpacks
,” Gait & Posture
, 82
, pp. 118
–125
.39.
Leng
, Y.
, Lin
, X.
, Yang
, L.
, Xu
, Y.
, and Fu
, C.
, 2020
, “Design of an Elastically Suspended Backpack With Tunable Stiffness
,” Proceedings of the 2020 5th International Conference on Advanced Robotics and Mechatronics (ICARM)
, Shenzhen, China
, Dec. 18–21
, pp. 359
–363
.40.
Rebula
, J. R.
, and Kuo
, A. D.
, 2015
, “The Cost of Leg Forces in Bipedal Locomotion: A Simple Optimization Study
,” PLoS ONE
, 10
(2
), p. e0117384
.41.
Li
, D.
, Li
, T.
, Li
, Q.
, Liu
, T.
, and Yi
, J.
, 2016
, “A Simple Model for Predicting Walking Energetics With Elastically-Suspended Backpack
,” J. Biomech.
, 49
(16
), pp. 4150
–4153
. 42.
Leng
, Y.
, Lin
, X.
, Deng
, R.
, Chang
, J.
, Yang
, L.
, Zhang
, K.
, and Fu
, C.
, 2021
, “Design and Implement an Elastically Suspended Back Frame for Reducing the Burden of Carrier
,” Proceedings of the 2021 6th IEEE International Conference on Advanced Robotics and Mechatronics (ICARM)
, Chongqing, China
, July 3–5
, pp. 236
–240
.43.
Chheta
, Y. R.
, Joshi
, R. M.
, Gotewal
, K. K.
, and ManoahStephen
, M.
, 2017
, “A Review on Passive Gravity Compensation
,” Proceedings of the 2017 International Conference of Electronics, Communication and Aerospace Technology (ICECA)
, Coimbatore, India
, Apr. 20–22
, pp. 184
–189
.44.
Peng
, Y.
, Bu
, W.
, and Chen
, J.
, 2022
, “Design of the Wearable Spatial Gravity Balance Mechanism
,” ASME J. Mech. Rob.
, 14
(3
), p. 031006
. 45.
Franco
, J. A.
, Gallego
, J. A.
, and Herder
, J. L.
, 2021
, “Static Balancing of Four-Bar Compliant Mechanisms With Torsion Springs by Exerting Negative Stiffness Using Linear Spring At the Instant Center of Rotation
,” ASME J. Mech. Rob.
, 13
(3
), p. 031010
. 46.
Tseng
, T.-Y.
, Lin
, Y.-J.
, Hsu
, W.-C.
, Lin
, L.-F.
, and Kuo
, C.-H.
, 2017
, “A Novel Reconfigurable Gravity Balancer for Lower-Limb Rehabilitation With Switchable Hip/Knee-Only Exercise
,” ASME J. Mech. Rob.
, 9
(4
), p. 041002
. 47.
Liu
, J.
, He
, Y.
, Yang
, J.
, Cao
, W.
, and Wu
, X.
, 2022
, “Design and Analysis of a Novel 12-DOF Self-Balancing Lower Extremity Exoskeleton for Walking Assistance
,” Mech. Mach. Theory
, 167
, p. 104519
.48.
Huang
, L.
, Yang
, Z.
, Wang
, R.
, and Xie
, L.
, 2020
, “Physiological and Biomechanical Effects on the Human Musculoskeletal System While Carrying a Suspended-Load Backpack
,” J. Biomech.
, 108
, pp. 109894
. 49.
Brockway
, J. M.
, 1986
, “Derivation of Formulae Used to Calculate Energy Expenditure in Man
,” The Weir
, pp. 11
.50.
Kim
, J.
, Lee
, G.
, Heimgartner
, R.
, Revi
, D. A.
, Karavas
, N.
, Nathanson
, D.
, Galiana
, I.
, et al, 2019
, “Reducing the Metabolic Rate of Walking and Running With a Versatile, Portable Exosuit
,” Science
, 365
(6454
), pp. 668
–672
.51.
Harman
, E.
, Han
, K. H.
, Frykman
, P.
, and Pandorf
, C.
, 2000
, The Effects of Walking Speed on the Biomechanics of Backpack Load Carriage
:, Defense Technical Information Center, Fort Belvoir, VA.Copyright © 2022 by ASME
You do not currently have access to this content.
