Abstract

The hydrogen concentration in zirconium alloys used in nuclear fuel cladding can be determined quantitatively, rapidly and non-destructively with a spatial resolution of 25 μm by neutron radiography. Because the total neutron cross section of hydrogen is more than one order of magnitude higher than that of zirconium, low concentrations of hydrogen can be measured. Calibration measurements have been performed and confirm the linear dependence of the total macroscopic neutron cross section on the hydrogen to zirconium atomic ratio as expected from theoretical analysis. The fast and non-destructive character of the method provides the possibility of in situ investigations. Examples of in situ investigations of the diffusion of hydrogen into Zircaloy-4 and of hydrogen uptake during steam oxidation are given. For the steam oxidation experiments a fast hydrogen uptake was found during the first 10 s. After this first step, the hydrogen concentration in the sample decreases slightly. If breakaway oxidation occurs, additional hydrogen absorption takes place. The hydrogen concentration can then increase by nearly one order of magnitude by this process. The influence of variations in the total gas flow and the steam flow on the hydrogen uptake was investigated, too.

Issue Section:
Research Papers
Keywords:
neutron radiography, zirconium alloys, hydrogen uptake

References

1.
Sepold
,
L.
,
Große
,
M.
,
Steinbrück
,
M.
, and
Stuckert
,
J.
, “
Severe Fuel Damage Experiments with Advanced Cladding Materials to be Performed in the QUENCH Facility (QUENCH-ACM)
,”
Proc. of the 16th Internat. Conf. on Nuclear Engineering (ICONE-16)
(CD-ROM), Orlando, FL, May 11–15,
2008
, ASME, New York, Paper ICONE16-48074.
Google Scholar
Crossref
Search ADS
 
2.
Stuckert
,
J.
,
Birchley
,
J.
,
Große
,
M.
,
Haste
,
T.
,
Sepold
,
L.
, and
Steinbrück
,
M.
, “
Experimental and Post-Test Calculation Results of the Integral Reflood Test QUENCH–12 with a VVER-Type Bundle
,”
Ann. Nucl. Energy
 0306-4549, Vol.
36
,
2009
, pp.
183
–
192
. https://doi.org/10.1016/j.anucene.2008.11.024
Google Scholar
Crossref
Search ADS
 
3.
Stuckert
,
J.
,
Birchley
,
J.
,
Große
,
M.
,
Jaeckel
,
B.
, and
Steinbrück
,
M.
, “
Experimental and Calculation Results of the Integral Reflood Test QUENCH–14 with M5@ Cladding Tubes
,”
Ann. Nucl. Energy
 0306-4549, Vol.
37
,
2010
, pp.
1036
–
1047
. https://doi.org/10.1016/j.anucene.2010.04.015
Google Scholar
Crossref
Search ADS
 
4.
Stuckert
,
J.
,
Große
,
M.
, and
Steinbrück
,
M.
, “
Experimental Results of Reflood Bundle Test QUENCH-15 with ZIRLOTM Cladding Tubes
,”
Proc. 2010 International Congress on Advances in Nuclear Power Plants (ICAPP ‘10)
, San Diego, CA, June 13–17,
2010
, La Grange Park, IL, Paper 10286.
5.
Wagner
,
C.
, “
Die Löslichkeit von Wasserdampf in ZrO2-Y2O3-Mischkristallen
,”
Ber. Bunsenges. Phys. Chem
, Vol.
72
,
1968
, pp.
778
–
781
.
Google Scholar
Crossref
Search ADS
 
6.
Steinbrück
,
M.
, “
Hydrogen Absorption by Zirconium Alloys at High Temperatures
,”
J. Nucl. Mater.
 0022-3115, Vol.
334
,
2004
, pp.
58
–
64
. https://doi.org/10.1016/j.jnucmat.2004.05.007
Google Scholar
Crossref
Search ADS
 
7.
Grosse
,
M.
,
Lehmann
,
E.
,
Vontobel
,
P.
, and
Steinbrueck
,
M.
, “
Quantitative Determination of Absorbed Hydrogen in Oxidised Zircaloy by Means of Neutron Radiography
,”
Nucl. Instrum. Methods Phys. Res. A
 0168-9002, Vol.
566
,
2006
, pp.
739
–
745
. https://doi.org/10.1016/j.nima.2006.06.038
Google Scholar
Crossref
Search ADS
 
8.
Grosse
,
M.
,
Steinbrueck
,
M.
,
Lehmann
,
E.
, and
Vontobel
,
P.
, “
Kinetics of Hydrogen Absorption and Release in Zirconium Alloys During Steam Oxidation
,”
Oxid. Met.
 0030-770X, Vol.
70
,
2008
, pp.
149
–
162
. https://doi.org/10.1007/s11085-008-9113-2
Google Scholar
Crossref
Search ADS
 
9.
Grosse
,
M.
,
Kühne
,
G.
,
Steinbrück
,
M.
,
Lehmann
,
E.
,
Vontobel
,
P.
, and
Stuckert
,
J.
, “
Quantification of Hydrogen Uptake of Steam-Oxidized Zirconium Alloys by Means of Neutron Radiography
,”
J. Phys.: Condens. Matter
 0953-8984, Vol.
20
,
2008
, pp. 104263. https://doi.org/10.1088/0953-8984/20/10/104263
10.
Große
,
M.
,
Lehmann
,
E.
,
Steinbrueck
,
M.
,
Kühne
,
G.
, and
Stuckert
,
J.
,
J. Nucl. Mater.
 0022-3115, Vol.
385
,
2009
, p. 339. https://doi.org/10.1016/j.jnucmat.2008.12.021
11.
Brachet
,
J. C.
 and
Vandenberghe
,
V.
, “
Comments to Papers of J. H. Kim et al. [1] and M. Große et al. [2] Recently Published in JNM “On the Hydrogen Uptake of Zircaloy-4 and M5TM Alloys Subjected to STeam Oxidation in the 1100–1250 °C Temperature Range
,”
J. Nucl. Mater.
 0022-3115, Vol.
395
,
2009
, pp.
169
–
172
. https://doi.org/10.1016/j.jnucmat.2009.09.017
Google Scholar
Crossref
Search ADS
 
12.
Grosse
,
M.
,
Steinbrueck
,
M.
, and
Stuckert
,
J.
, “
Parameters Influencing the Secondary Hydrogenation of Zr-Sn and Zr-Nb Alloys During Steam Oxidation Under LOCA and Severe Accident Conditions
,”
Proc. 18th Intern. Conf. on Nucl. Engin. ICONE18
(CD-ROM), Xi’an, China, May 17–21,
2010
, Paper ICONE18-29405.
Google Scholar
Crossref
Search ADS
 
13.
Simeno
,
M.
,
Nippon Kinzoku Gakkaishi
 0021-4876, Vol.
24
,
1960
, pp.
249
–
254
.
14.
Gelezunas
,
V. L.
,
Conn
,
P. G.
, and
Price
,
R. H.
, “
The Difference Coefficients for Hydrogen in β-Zirconium
,”
J. Electrochem. Soc.
 0013-4651, Vol.
110
,
1963
, pp.
799
–
805
. https://doi.org/10.1149/1.2425875
Google Scholar
Crossref
Search ADS
 
This content is only available via PDF.
All rights reserved. This material may not be reproduced or copied, in whole or in part, in any printed, mechanical, electronic, film, or other distribution and storage media, without the written consent of ASTM International.
You do not currently have access to this content.