Radiation would be more important in turbine heat transfer due to higher temperature and multicomposition gas conditions in the future. The main goal of the current study is analyzing the characteristics of conjugate heat transfer considering radiation heat transfer, multicomposition gas, either with or without TBC coated. Both experimental and numerical studies were carried out. By comparing the experimental and the numerical results, it was concluded that the implemented thermal conduction/convection/radiation simulation method is valid for the cases studied. The results have shown that higher percentage of steam in the gas composition leads to higher temperature (lower normalized temperature) on the plate. With the percentage of steam in the hot gas increasing per 7%, the normalized temperature on the plate decreases about 0.02. The heat insulation effect of TBC is more obvious when the radiation effects are strong.

References

References
1.
Mazzotta
,
D. W.
,
Chyu
,
M. K.
, and
Alvin
,
M. A.
,
2007
, “
Airfoil Heat Transfer Characteristics in Syngas and Hydrogen Turbines
,”
ASME
Paper No. GT2007-28296.
2.
Hylton
,
L. D.
,
Milhec
,
M. S.
,
Turner
,
E. R.
,
Nealy
,
D. A.
, and
York
,
R. E.
,
1983
, “
Analytical and Experimental Evaluation of the Heat Transfer Distribution Over the Surface of Turbine Vanes
,” Report No. NASA CR 168015.
3.
Hylton
,
L. D.
,
Nirmalan
,
V.
,
Sultanian
,
B. K.
, and
Kaufman
,
R. M.
,
1988
, “
The Effects of Leading Edge and Downstream Film Cooling on Turbine Vane Heat Transfer
,” Report No. NASA CR 182133.
4.
Dees
,
J. E.
,
Bogard
,
D. G.
,
Ledezma
,
G. A.
,
Laskowski
,
G. M.
, and
Tolpadi
,
A. K.
,
2012
, “
Experimental Measurements and Computational Predictions for an Internally Cooled Simulated Turbine Vane
,”
ASME J. Turbomach.
,
134
(
6
), p.
061003
.
5.
Dees
,
J. E.
,
Bogard
,
D. G.
,
Ledezma
,
G. A.
, and
Laskowski
,
G. M.
,
2011
, “
The Effects of Conjugate Heat Transfer on the Thermal Field Above a Film Cooled Wall
,”
ASME
Paper No. GT 2011-46617.
6.
Kumar
,
A.
, and
Kale
,
S. R.
,
2002
, “
Numerical Simulation of Steady State Heat Transfer in a Ceramic-Coated Gas Turbine Blade
,”
Int. J. Heat Mass Transfer
,
45
(
24
), pp.
4831
4845
.
You do not currently have access to this content.