In Part I of this two-part paper on swirling gas–liquid two-phase flow, correlations have been developed for the continuous liquid-phase velocity field under swirling conditions, such as that occurring in the lower part of the Gas–Liquid Cylindrical Cyclone (GLCC©1) compact separator. The developed correlations, including the axial, tangential, and radial velocity distributions, are applicable for swirling flow in both cyclones and pipe flow. The first objective of this paper is to extend the study of Part I by developing correlations for the turbulent quantities of the continuous liquid phase, including the turbulent kinetic energy and its dissipation rate and Reynolds shear stresses. The second objective is to study experimentally and theoretically two-phase swirling flow gas-core characteristics and stability. The first objective has been met utilizing local LDV measurements acquired for swirling flow. The developed turbulent quantities correlations have been tested against data from other studies, showing good agreement. For the second objective, experimental data have been acquired under swirling two-phase flow conditions. A model for the prediction of the gas-core diameter and stability in swirling flow field has been developed, based on the turbulent kinetic energy behavior predicted by the developed correlations. Good agreement is observed between the model predictions and the data.

Keywords:
swirling flow, confined flow, flow measurement, turbulence, Doppler measurement, two-phase flow, flow instability
Topics:
Kinetic energy, Swirling flow, Turbulence
1.
Gomez
,
L.
,
Mohan
,
R.
,
Shoham
,
O.
, and
Kouba
,
G.
,
2000
, “
Enhanced Mechanistic Model and Field Application Design of Gas–Liquid Cylindrical Cyclone Separator
,”
SPE J.
,
5
, pp.
190
–
198
.
2.
Nissan
,
A. H.
, and
Bresan
,
V. P.
,
1961
, “
Swirling Flow in Cylinders
,”
AIChE J.
,
7
, pp.
543
–
547
.
3.
Ito
,
S.
,
Ogawa
,
K.
, and
Kuroda
,
C.
,
1979
, “
Decay Process of Swirling Flow in a Circular Pipe
,”
Int. Chem. Eng.
,
19
, pp.
600
–
611
.
4.
Algifri
,
A. H.
,
Bhardwaj
,
R. K.
, and
Rao
,
Y. V. N.
,
1988
, “
Eddy Viscosity in Decaying Swirl Flow in a Pipe
,”
Appl. Sci. Res.
,
45
, pp.
287
–
302
.
5.
Kitoh
,
O.
,
1991
, “
Experimental Study of Turbulent Swirling Flow in a Straight Pipe
,”
J. Fluid Mech.
,
225
, pp.
445
–
479
.
6.
Yu
,
S. C. M.
, and
Kitoh
,
O.
,
1994
, “
General Formulation for the Decay of Swirling Motion Along a Straight Pipe
,”
Int. Commun. Heat Mass Transfer
,
21
, pp.
719
–
728
.
7.
Chang
,
F.
, and
Dhir
,
V. K.
,
1994
, “
Turbulent Flow Field in Tangentially Injected Swirl Flows in Tubes
,”
Int. J. Heat Fluid Flow
,
15
, pp.
346
–
356
.
8.
Kurokawa, J., 1995, “Gas–Liquid Flow Characteristics and Gas-Separation Efficiency in a Cyclone Separator,” ASME FED-Vol. 225, Gas Liquid Flows, pp. 51–57.
9.
Erdal, F., 2001, “Local Measurements and Computational Fluid Dynamic Simulations in a Gas–Liquid Cylindrical Cyclone Separator,” Ph.D. dissertation, The University of Tulsa.
10.
Mantilla, I., 1998, “Bubble Trajectory Analysis in GLCC Separators,” M.S. thesis, The University of Tulsa.
11.
Gomez, L. E., 1998, “A State-of-the Art Simulator and Field Application Design of Gas-Liquid Cylindrical Cyclone Separators,” M.S. thesis, The University of Tulsa.
12.
Gomez, L. E., 2001, “Dispersed Two-Phase Swirling Flow Characterization for Predicting Gas Carry-Under in Gas-Liquid Cylindrical Cyclone Compact Separator,” Ph.D. dissertation, The University of Tulsa.
13.
Kobayashi
,
T.
, and
Yoda
,
M.
,
1987
, “
Modified k-e Model for Turbulent Swirling Flow in a Straight Pipe
,”
JSME Int. J.
,
30
, p.
66
66
.
14.
Barrientos, A., Sampaio, R., and Concha, F., 1993, “Effect of the Air Core on the Performance of a Hydrocyclone,” XVIII International Mineral Processing Conference, Sydney, pp. 267–270.
Copyright © 2004
 by ASME
You do not currently have access to this content.