Simulation of the transient motion of pigs through liquid and gas pipelines is presented. The differential form of the mass and linear momentum equations for compressible liquid and gas flows were solved by a finite difference numerical technique. The fluid flow equations were combined with a linear momentum equation for the pig and a model for bypass flow through the pig. The pig/wall contact forces were simulated by a stick/slip model. The contact forces developed by disk pigs and the pipe wall were predicted by a postbuckling finite element analysis of the discs. Test cases representing typical pigging operations were studied using the numerical model developed. The fluid flow and pig behavior predicted by the model presented a reasonable behavior, and contributed for a better understanding of the pig dynamics through gas and liquid pipelines.

Issue Section:
Technical Papers
Keywords:
pipe flow, transients, motion control, gases, liquids, simulation, differential equations, fluid dynamics, mass transfer
Topics:
Disks, Flow (Dynamics), Fluid dynamics, Fluids, Pipeline risers, Pipelines, Pipes, Pressure, Risers (Casting), Transients (Dynamics), Simulation, Flanges, Dynamics (Mechanics), Dewatering
1.
Sullivan, J. M., 1981, “An Analysis of the Motion of Pigs Through Natural Gas Pipelines,” Master’s thesis, Department of Mechanical Engineering, Rice University.
2.
Haun
,
R.
,
1986
, “
Analysis and Modeling of Pipeline Dewatering and Startup, Part 1
,”
Pipeline Industry
,
pp.
37
–
41
.
3.
Burt, E. G. C., and MacDonald, R., 1997, “Pig Signaling, Location and Tracking,” The Pipeline Pigging Conference, Houston, PA.
4.
Cordell, J. L., 1986, “Design of Pigs for Subsea Systems,” Proc., Conference on Subsea Pigging, Haugesund, Norway, Pipes & Pipelines International.
5.
Gomes, M. G. F. M., 1994, “Finite Element Analysis of Pig Cups for Pipeline Cleaning,” Master’s thesis, Department of Mechanical Engineering, Federal University of Rio de Janeiro, Brazil (in Portuguese).
6.
Short
,
G. C.
,
1994
, “
The Pigging Technology Project: The First Three Years
,”
Pipes & Pipelines Int.
,
39-4
, pp.
23
–
27
7.
Azevedo, L. F. A. Braga, A. M. B., Nieckele, A. O., Naccache, M. F., and Gomes, M. G. F., 1995, “Simple Hydrodynamic Models for the Prediction of Pig Motion in Pipelines,” Pipeline Pigging Conference, Houston, PA.
8.
Azevedo, L. F. A., Braga, A. M. B., and Gomes M. G. F. M., 1997, “Experimental Validation of Analytical Numerical Models for By-pass Flow and Contact Forces in Pig Cups,” The Pipeline Pigging Conference, Houston, PA.
9.
Santos, O. G., Alhanati, J. S. and Bordalo, S. N., 1997, “Modeling and Performance of Pig-Lift,” XIV Brazilian Congress of Mechanical Engineering—COBEM, Sa˜o Paulo, Brazil.
10.
Azevedo, L. F. A. Braga, A. M. B., Nieckele, A. O., and Souza Mendes, P. R., 1999, “Simulating Pipeline Pigging Operations,” Proc. The Pipeline Pigging Conference, Stavanger, Norway, pp. 1–21.
11.
Vianes Campo, E., and Rachid, F. B., 1997, “Modeling of Pig Motion Under Transient Fluid Flow,” Proc. XIV Brazilian Congress of Mechanical Engineering—COBEM, Sa˜o Paulo, Brazil.
12.
Nieckele, A. O., Braga, A. M. B., and Azevedo, L. F. A., 2000, “Transient Pig Motion Through Gas and Liquid Pipelines,” Proc. ETCE/OMAE2000 Joint Conference, ETCE2000/PROD-10317, New Orleans, LA.
13.
Braga, A. M. B., Azevedo, L. F. A., Nieckele, A. O., and Souza Mendes, P. R., 1998, “Pipeline Pigging Simulation Project,” Final Report, Department of Mechanical Engineering, PUC-Rio, Brazil.
14.
Wylie, E. B., and Streeter, V. L., 1978, Compressible Flow in Pipes, McGraw- Hill, New York, NY.
15.
Fox, R. W., and McDonald, A. T., 1995, Introduction to Fluid Mechanics, McGraw Hill, New York, NY.
16.
Patankar, S. V., 1980, Numerical Heat Transfer and Fluid Flow, Hemisphere Publishing Co., New York, NY.
17.
Versteeg, H. K., and Malalasekera, W., 1995, An Introduction to Computational Fluid Dynamics—The Finite Volume Method, Longman Scientific & Technical, England.
18.
Vingerhagen, A., and Falck, C., 1997, “The Development and Testing of a 40-in. High-Friction Pig,” Pipeline Pigging Conference, Houston, PA.
Copyright © 2001
 by ASME
You do not currently have access to this content.