https://orcid.org/0000-0002-2886-9096
Abstract
Superabsorbent polymers (SAP) have been investigated as an additive for use in the manufacture of internally cured concrete. The ability of SAP to absorb and desorb fluid is important for the design of internally cured concrete mixtures. Internal curing research on lightweight aggregates (LWA) has typically focused on the absorption of water in the LWA internal curing agent. However, when SAP is used, the absorption test should be performed using a pore solution with a defined ionic concentration. To address the effect of the ionic composition of the pore solution on SAP absorption, pore solutions were extracted from fresh cementitious pastes, and their composition was evaluated using X-ray fluorescence. This study characterizes the absorption and desorption of a commercially available SAP, using both simulated and extracted pore solutions with a range of ionic concentrations. The teabag method was implemented to measure the absorption of the SAP. As expected, the absorption of the SAP decreased in solutions with higher ionic concentrations. In addition to studying solutions extracted from ordinary portland cement pastes, the effects of the inclusion of supplementary cementitious materials on the SAP absorption were studied. Results showed that the inclusion of supplementary cementitious materials had a relatively minor impact on the SAP absorption, primarily due to a dilution of the ionic concentration of the pore solution. This article examined the desorption of the SAP in two conditions: a reduction in the ambient relative humidity and after exposure of the SAP to solutions with a higher ionic concentration. It was observed that SAP-containing solutions with a higher ionic concentration had a reduced rate of desorption and a reduced overall desorption at a given relative humidity. In addition, moving the SAP from a solution with a lower ionic concentration to a more highly concentrated solution resulted in desorption. An equation was developed that expresses the SAP absorption as a function of the pH of the soaking solution. The expression was used to predict the desorption of SAP due to an increase in the ionic concentrations in a hydrating system. This equation was used to show that the desorption of SAP due to changes in the pore solution ionic concentration were significant during the first 72 hours. The findings and the techniques used in this study are meant to be used as an example for the characterization of SAP in concrete internal curing applications.
Issue Section:
Technical Papers
References
1.
RILEM Technical Committee 225
Application of Superabsorbent Polymers (SAP) in Concrete Construction
, Mechtcherine
V.
and Reinhardt
H.-W.
, Eds., Springer
, Dordrecht, Germany
, 2012
, 159p, https://doi.org/10.1007/978-94-007-2733-52.
ACI Committee 308-213 “
R-13 Report on Internally Cured Concrete Using Prewetted Absorptive Lightweight Aggregate
,” American Concrete Institute, Farmington Hills, MI, 2013
, pp. 1
–12
.3.
Castro
, J.
, Peled
, A.
, and Weiss
, W. J.
, “Full and Partial Internal Curing in Mortar in Terms of Internal Relative Humidity, Hydration and Performance
,” presented at the Eleventh International Society of Concrete Pavements
, San Antonio, TX, Aug. 28–Sep. 1, 2016
, International Society for Concrete Pavements
, Bridgeville, PA
.4.
Kovler
, K.
and Jensen
, O. M.
, “Novel Techniques for Concrete Curing
,” Concr. Int.
, Vol. 27
, No. 9
, 2005
, pp. 39
–42
.5.
RILEM Technical Committee TC 181-EAS
Report 25: Early Age Cracking in Cementitious Systems
, RILEM Publications
, Paris, France
, 2003
, 337p.6.
Cusson
, D.
and Hoogeveen
, T.
, “Internal Curing of High-Performance Concrete with Pre-Soaked Fine Lightweight Aggregate for Prevention of Autogenous Shrinkage Cracking
,” Cem. Concr. Res.
, Vol. 38
, No. 6
, 2008
, pp. 757
–765
, https://doi.org/10.1016/j.cemconres.2008.02.0017.
Bentz
, D. P.
and Weiss
, W. J.
, “Internal Curing: A 2010 State of the Art Review
,” NIST Report 7765
, National Institute of Standards and Technology
, 2011
, 82p.8.
Montanari
, L.
, Suraneni
, P.
, and Weiss
, W. J.
, “Accounting for Water Stored in Superabsorbent Polymers in Increasing the Degree of Hydration and Reducing the Shrinkage of Internally Cured Cementitious Mixtures
,” Adv. Civ. Eng. Mater.
, Vol. 6
, No. 1
, 2017
, pp. 583
–599
, https://doi.org/10.1520/ACEM201700989.
Hasholt
, M. T.
, Jensen
, O. M.
, Kovler
, K.
, and Zhutovsky
, S.
, “Can Superabsorbent Polymers Mitigate Autogenous Shrinkage of Internally Cured Concrete without Compromising the Strength?
,” Constr. Build. Mater.
, Vol. 31
, 2012
, pp. 226
–230
, https://doi.org/10.1016/j.conbuildmat.2011.12.06210.
Schröfl
, C.
, Mechtcherine
, V.
, and Gorges
, M.
, “Relation between the Molecular Structure and the Efficiency of Superabsorbent Polymers (SAP) as Concrete Admixture to Mitigate Autogenous Shrinkage
,” Cem. Concr. Res.
, Vol. 42
, No. 6
, 2012
, pp. 865
–873
, https://doi.org/10.1016/j.cemconres.2012.03.01111.
Jensen
, O. M.
and Hansen
, P. F.
, “Water-Entrained Cement-Based Materials: II. Experimental Observations
,” Cem. Concr. Res.
, Vol. 32
, No. 6
, 2002
, pp. 973
–978
, https://doi.org/10.1016/S0008-8846(02)00737-812.
Wang
, F.
, Zhou
, Y.
, Peng
, B.
, Liu
, Z.
, and Hu
, S.
, “Autogenous Shrinkage of Concrete with Super-Absorbent Polymer
,” ACI Mater. J.
, Vol. 106
, No. 2
, 2009
, pp. 123
–127
.13.
Shah
, S. P.
, Weiss
, W. J.
, and Yang
, W.
, “Shrinkage Cracking—Can it be Prevented?
,” Concr. Int.
, Vol. 20
, No. 4
, 1998
, pp. 51
–55
.14.
Geiker
, M.
, Bentz
, D.
, and Jensen
, O.
, “Mitigating Autogenous Shrinkage by Internal Curing
,” ACI SP-218
, 2004
, pp. 143
–148
.15.
Snyder
, K. A.
and Bentz
, D. P.
, “Protected Paste Volume in Concrete: Extension to Internal Curing Using Saturated Lightweight Fine Aggregate
,” Cem. Concr. Res.
, Vol. 29
, No. 11
, 1999
, pp. 1863
–1867
, https://doi.org/10.1016/S0008-8846(99)00178-716.
Montanari
, L.
, Amirkhanian
, A. N.
, Suraneni
, P.
, and Weiss
, W. J.
, “Toward a Mixture Design Methodology for Partial Volumes of Internal Curing Water Based on the Reduction of Autogenous Shrinkage
,” J. Mater. Civ. Eng.
(in press).17.
Friggle
, T.
and Reeves
, D.
, “Internal Curing of Concrete Paving: Laboratory and Field Experience
,” ACI SP-256
, 2008
, pp. 71
–80
.18.
Lura
, P.
, Felix
, D.
, Loukili
, A.
, Kovler
, K.
, and Jensen
, O. M.
, “Compressive Strength of Cement Pastes and Mortars with Superabsorbent Polymers
,” presented at the International RILEM Conference on Volume Changes of Hardening Concrete: Testing and Mitigation
, Lyngby, Denmark, Aug. 20–23, 2006
, RILEM
, Paris, France
.19.
Farzanian
, K.
, Pimenta Teixeira
, K.
, Perdigão Rocha
, I.
, De Sa Carneiro
, L.
, and Ghahremaninezhad
, A.
, “The Mechanical Strength, Degree of Hydration, and Electrical Resistivity of Cement Pastes Modified with Superabsorbent Polymers
,” Constr. Build. Mater.
, Vol. 109
, 2016
, pp. 156
–165
, https://doi.org/10.1016/j.conbuildmat.2015.12.08220.
Henkensiefken
, R.
, Castro
, J.
, Bentz
, D.
, Nantung
, T.
, and Weiss
, J.
, “Water Absorption in Internally Cured Mortar Made with Water-Filled Lightweight Aggregate
,” Cem. Concr. Compos.
, Vol. 39
, No. 10
, 2009
, pp. 883
–892
, https://doi.org/10.1016/j.cemconres.2009.06.00921.
Henkensiefken
, R.
, Bentz
, D. P.
, Nantung
, T.
, and Weiss
, W. J.
, “Volume Change and Cracking in Internally Cured Mixtures Made with Saturated Lightweight Aggregate under Sealed and Unsealed Conditions
,” Cem. Concr. Compos.
, Vol. 31
, No. 7
, 2009
, pp. 427
–437
, https://doi.org/10.1016/j.cemconcomp.2009.04.00322.
Schlitter
, J.
, Henkensiefken
, R.
, Castro
, J.
, Raoufi
, K.
, and Weiss
, J.
, Development of Internally Cured Concrete for Increased Service Life, Final Report FHWA/IN/JTRP-2010/10
, Indiana Department of Transportation
, West Lafayette, IN
, 2010
, 289p.23.
Byard
, B. E.
, Schindler
, A. K.
, and Barnes
, R. W.
, “Cracking Tendency of Lightweight Aggregate Deck Concrete
,” ACI Mater. J.
, Vol. 111
, No. 2
, 2010
, pp. 179
–188
.24.
Bentz
, D. P.
, “Influence of Internal Curing Using Lightweight Aggregates on Interfacial Transition Zone Percolation and Chloride Ingress in Mortars
,” Cem. Concr. Compos.
, Vol. 31
, No. 5
, 2009
, pp. 285
–289
, https://doi.org/10.1016/j.cemconcomp.2009.03.00125.
Di Bella
, C.
, Villani
, C.
, Phares
, N.
, Hausheer
, E.
, and Weiss
, J.
, “Chloride Transport and Service Life in Internally Cured Concrete
,” presented at the Structures Congress 2012
, Chicago, IL, Mar. 29–31, American Society of Civil Engineers
, Reston, VA
, 2012
, pp. 686
–698
.26.
Craeye
, B.
, Geirnaert
, M.
, and Schutter
, G. D.
, “Super Absorbing Polymers as an Internal Curing Agent for Mitigation of Early-Age Cracking of High-Performance Concrete Bridge Decks
,” Constr. Build. Mater.
, Vol. 25
, No. 1
, 2011
, pp. 1
–13
, https://doi.org/10.1016/j.conbuildmat.2010.06.06327.
Bentz
, D. P.
, Lura
, P.
, and Roberts
, J. W.
, “Mixture Proportioning for Internal Curing
,” Concr. Int.
, Vol. 27
, No. 2
, 2005
, pp. 35
–40
.28.
ASTM C150/150M
Standard Specification for Portland Cement
, ASTM International
, West Conshohocken, PA
, 2017
, www.astm.org29.
ASTM C618
Standard Specification for Coal Fly Ash and Raw or Calcined Natural Pozzolan for Use in Concrete
, ASTM International
, West Conshohocken, PA
, 2015
, www.astm.org30.
ASTM C114
Standard Test Methods for Chemical Analysis of Hydraulic Cement
, ASTM International
, West Conshohocken, PA
, 2015
, www.astm.org31.
Rajabipour
, F.
, Sant
, G.
, and Weiss
, J.
, “Interactions between Shrinkage Reducing Admixtures (SRA) and Cement Paste’s Pore Solution
,” Cem. Concr. Res.
, Vol. 38
, No. 5
, 2008
, pp. 606
–615
, https://doi.org/10.1016/j.cemconres.2007.12.00532.
Tsui-Chang
, M.
, Suraneni
, P.
, Montanari
, L.
, and Weiss
, W. J.
, “Determination of Chemical Composition and Electrical Resistivity of Expressed Cementitious Pore Solution Using X-Ray Fluorescence
,” ACI Mater. J.
(in press).33.
ASTM C191
Standard Test Method for Time of Setting of Hydraulic Cement by Vicat Needle
, ASTM International
, West Conshohocken, PA
, 2014
, www.astm.org34.
Tsui Chang
, M.
, Suraneni
, P.
, Isgor
, O. B.
, Trejo
, D.
, and Weiss
, W. J.
, “Using X-Ray Fluorescence to Assess the Chemical Composition and Resistivity of Simulated Cementitious Pore Solutions
,” Int. J. Adv. Eng. Sci. Appl. Math.
, Vol. 9
, No. 3
, 2017
, pp. 136
–143
, https://doi.org/10.1007/s12572-017-0181-x35.
Parrot
, L. J.
and Killoh
, D. C.
, “Prediction of Cement Hydration
,” Br. Ceram. Proc.
, Vol. 35
, 1984
, pp. 41
–53
.36.
Lothenbach
, B.
and Winnefeld
, F.
, “Thermodynamic Modelling of the Hydration of Portland Cement
,” Cem. Concr. Res.
, Vol. 36
, No. 2
, 2006
, pp. 209
–226
, https://doi.org/10.1016/j.cemconres.2005.03.00137.
Powers
, T. C.
and Brownyard
, T. L.
, “Studies of the Physical Properties of Hardened Portland Cement Paste
,” J. Am. Concr. Inst.
, Vol. 43
, No. 9
, 1946
, pp. 469
–504
.38.
Miller
, A. E.
, Barrett
, T. J.
, and Weiss
, W. J.
, “Evaluation of Superabsorbent Polymers for Use in Cementitious Systems for the Purpose of Mitigating Autogenous Shrinkage
,” presented at the International RILEM Conference on the Application of Superabsorbent Polymers and Other New Admixtures in Concrete Construction
, Dresden, Germany, Sep. 14
–17
, 2014
, RILEM
, Paris, France
.39.
Schröfl
, C.
, Snoeck
, D.
, and Mechtcherine
, V.
, “A Review of Characterisation Methods for Superabsorbent Polymer (SAP) Samples to be Used in Cement-Based Construction Materials: Report of the RILEM TC 260-RSC
,” Mater. Struct.
, Vol. 50
, No. 4
, 2017
, pp. 197
–216
, https://doi.org/10.1617/s11527-017-1060-440.
Zhao
, Y.
, Su
, H.
, Fang
, L.
, and Tan
, T.
, “Superabsorbent Hydrogels from Poly(Aspartic Acid) with Salt-, Temperature- and pH-Responsiveness Properties
,” Polymer
, Vol. 46
, No. 14
, 2005
, pp. 5368
–5376
, https://doi.org/10.1016/j.polymer.2005.04.01541.
Zohuriaan-Mehr
, M. J.
and Kabiri
, K.
, “Superabsorbent Polymer Materials: A Review
,” Iran Polym. J.
, Vol. 17
, No. 6
, 2008
, pp. 451
–477
.42.
Mönnig
, S.
, “Superabsorbing Additions in Concrete—Applications, Modelling and Comparison of Different Internal Water Sources
,” Ph.D. Thesis, University of Stuttgart
, Stuttgart, Germany, 2009
.43.
Farzanian
, K.
and Ghahremaninezhad
, A.
, “The Effect of the Capillary Forces on the Desorption of Hydrogels in Contact with a Porous Cementitious Material
,” Mater. Struct.
, Vol. 50
, No. 5
, 2017
, pp. 216
–231
, https://doi.org/10.1617/s11527-017-1068-944.
Castro
, J.
, Keiser
, L.
, Golias
, M.
, and Weiss
, J.
, “Absorption and Desorption Properties of Fine Lightweight Aggregate for Application to Internally Cured Concrete Mixtures
,” Cem. Concr. Compos.
, Vol. 33
, No. 10
, 2011
, pp. 1001
–1008
, https://doi.org/10.1016/j.cemconcomp.2011.07.00645.
ASTM C1761
Standard Specification for Lightweight Aggregate for Internal Curing of Concrete
, ASTM International
, West Conshohocken, PA
, 2015
, www.astm.org46.
Esteves
, L. P.
, “Superabsorbent Polymers: On Their Interaction with Water and Pore Fluid
,” Cem. Concr. Compos.
, Vol. 33
, No. 7
, 2011
, pp. 717
–724
, https://doi.org/10.1016/j.cemconcomp.2011.04.00647.
Andersson
, K.
, Allard
, B.
, Bengtsson
, M.
, and Magnusson
, B.
, “Chemical Composition of Cement Pore Solutions
,” Cem. Concr. Res.
, Vol. 19
, No. 3
, 1989
, pp. 327
–332
, https://doi.org/10.1016/0008-8846(89)90022-748.
Zhu
, Q.
, Barney
, C. W.
, and Erk
, K. A.
, “Effect of Ionic Crosslinking on the Swelling and Mechanical Response of Model Superabsorbent Polymer Hydrogels for Internally Cured Concrete
,” Mater. Struct.
, Vol. 48
, No. 7
, 2015
, pp. 2261
–2276
, https://doi.org/10.1617/s11527-014-0308-549.
Horkay
, F.
, Tasaki
, I.
, and Basser
, P. J.
, “Effect of Monovalent-Divalent Cation Exchange on the Swelling of Polyacrylate Hydrogels in Physiological Salt Solutions
,” Biomacromolecules
, Vol. 2
, No. 1
, 2001
, pp. 195
–199
, https://doi.org/10.1021/bm005615350.
Shehata
, M. H.
, Thomas
, M. D. A.
, and Bleszynski
, R. F.
, “The Effects of Fly Ash Composition on the Chemistry of Pore Solution in Hydrated Cement Pastes
,” Cem. Concr. Res.
, Vol. 29
, No. 12
, 1999
, pp. 1915
–1920
, https://doi.org/10.1016/S0008-8846(99)00190-851.
Vollpracht
, A.
, Lothenbach
, B.
, Snellings
, R.
, and Haufe
, J.
, “The Pore Solution of Blended Cements: A Review
,” Mater. Struct.
, Vol. 49
, No. 8
, 2016
, pp. 3341
–3367
, https://doi.org/10.1617/s11527-015-0724-152.
Greenspan
, L.
, “Humidity Fixed Points of Binary Saturated Aqueous Solutions
,” J. Res. Natl. Bur. Stand.—A. Phys. Chem.
, Vol. 81A
, No. 1
, 1977
, pp. 89
–96
, https://doi.org/10.6028/jres.081A.011
This content is only available via PDF.
All rights reserved. This material may not be reproduced or copied, in whole or part, in any printed, mechanical, electronic, film, or other distribution and storage media, without the written consent of ASTM International.
You do not currently have access to this content.
