Abstract

Various researchers have used the viscosity ratio to quantify the aging characteristics of asphalt binder. The calculation of this viscosity ratio requires viscosity values of asphalt binder under unaged and aged conditions. The asphalt binder is aged under laboratory conditions using a rolling thin film oven (RTFO) for 85 minutes at 163°C. Because of its failure to capture the aging characteristics completely, researchers have some apprehensions regarding the use of the viscosity ratio to characterize the aging susceptibility of asphalt. Several researchers have reported that activation energy is a fundamental property of a material and can be accurately related to the temporal changes within the material. This article presents a reaction kinetics-based activation energy approach to quantify the changes in the viscosity of asphalt binder when exposed to an elevated temperature. For this purpose, three distinct asphalt binders were aged using RTFO under laboratory conditions for an extended period. The viscosity of unaged and aged binders was measured using a rotational viscometer over a range of temperatures. These viscosity measurements were used to compute the aging index and viscous flow activation energy. The test results and subsequent analysis indicated that the aging index was able to capture short-term aging effects to a limited extent for unmodified asphalt, but it failed with modified asphalt binders. Also, the rankings of binders based on the aging index were inconsistent over the range of temperatures used in this study. On the other hand, the computed activation energy and rate of change in activation energy showed a strong correlation with aging time. Thus, it can be concluded that the RTFO aging process combined with the viscous flow activation energy can be used to quantify the aging characteristics of asphalt binder accurately.

References

1.
Cortizo
,
M. S.
,
Larsen
,
D. O.
,
Bianchetto
,
H.
, and
Alessandrini
,
J. L.
, “
Effect of the Thermal Degradation of SBS Copolymers during the Ageing of Modified Asphalts
,”
Polym. Degrad. Stab.
, Vol. 
86
, No. 
2
,
2004
, pp. 
275
282
, https://doi.org/10.1016/j.polymdegradstab.2004.05.006
2.
Ding
,
G.
, “
Study on Absorbing-Oxygen Aging Performances of Paving Asphalt
,”
Pet. Process.
, Vol. 
5
,
1990
, 42p.
3.
Herrington
,
P. R.
and
Ball
,
G. F. A.
, “
Temperature Dependence of Asphalt Oxidation Mechanism
,”
Fuel
, Vol. 
75
, No. 
9
,
1996
, pp. 
1129
1131
, https://doi.org/10.1016/0016-2361(96)00042-7
4.
Huang
,
S.-C.
,
Glaser
,
R.
, and
Turner
,
F.
, “
Impact of Water on Asphalt Aging: Chemical Aging Kinetic Study
,”
Transp. Res. Rec.
, Vol. 
2293
,
2012
, pp. 
63
72
, https://doi.org/10.3141/2293-08
5.
Peterson
,
J. C.
, “
Asphalt Oxidation—An Overview Including a New Model for Oxidation Proposing that Physicochemical Factors Dominate the Oxidation Kinetics
,”
Fuel Sci. Technol. Int.
, Vol. 
11
,
2007
, pp. 
57
87
, https://doi.org/10.1080/08843759308916058
6.
Xiao
,
F.
,
Amirkhanian
,
S. N.
,
Karakouzian
,
M.
, and
Khalili
,
M.
, “
Rheology Evaluations of WMA Binders Using Ultraviolet and PAV Aging Procedures
,”
Constr. Build. Mater.
, Vol. 
79
,
2015
, pp. 
56
64
, https://doi.org/10.1016/j.conbuildmat.2015.01.046
7.
Zeng
,
W.
,
Wu
,
S.
,
Wen
,
J.
, and
Chen
,
Z.
, “
The Temperature Effects in Aging Index of Asphalt during UV Aging Process
,”
Constr. Build. Mater.
, Vol. 
93
,
2015
, pp. 
1125
1131
, https://doi.org/10.1016/j.conbuildmat.2015.05.022
8.
Kandhal
,
P.
and
Chakraborty
,
S.
, “
Effect of Asphalt Film Thickness on Short- and Long-Term Aging of Asphalt Paving Mixtures
,”
Transp. Res. Rec.
, Vol. 
1535
,
1996
, pp. 
83
90
, https://doi.org/10.3141/1535-11
9.
Lee
,
M.-G.
,
Tia
,
M.
,
Ruth
,
B. E.
, and
Page
,
G. C.
, “
Comparison between the Aging Processes for Asphalt Mixtures and Those for Asphalt Binders
,”
Progress of Superpave (Superior Performing Asphalt Pavement): Evaluation and Implementation, ASTM STP12084S
,
Jester
R. N.
, Ed.,
ASTM International
,
West Conshohocken, PA
,
1997
, pp. 
126
134
, https://doi.org/10.1520/STP12084S
10.
Lu
,
X.
and
Isacsson
,
U.
, “
Chemical and Rheological Evaluation of Ageing Properties of SBS Polymer Modified Bitumens
,”
Fuel
, Vol. 
77
, Nos. 
9–10
,
1998
, pp. 
961
972
, https://doi.org/10.1016/S0016-2361(97)00283-4
11.
Lu
,
X.
and
Isacsson
,
U.
, “
Effect of Ageing on Bitumen Chemistry and Rheology
,”
Constr. Build. Mater.
, Vol. 
16
, No. 
1
,
2002
, pp. 
15
22
, https://doi.org/10.1016/S0950-0618(01)00033-2
12.
Shenoy
,
A.
, “
Prediction of High Temperature Rheological Properties of Aged Asphalts from the Flow Data of the Original Unaged Samples
,”
Constr. Build. Mater.
, Vol. 
16
, No. 
8
,
2002
, pp. 
509
517
, https://doi.org/10.1016/S0950-0618(02)00030-2
13.
Van Goosswillingen
,
G.
,
de Bats
,
F. T.
, and
Berger
,
H.
, “
Oxidation of Bitumens in Various Tests
,” presented at the
Third Eurobitume Symposium
, The Hague, Netherlands, Sept. 11–13,
1985
,
Eurobitume
,
Brussels, Belgium
, pp. 
95
101
.
14.
Kemp
,
G. R.
and
Predoehl
,
N. H.
, “
A Comparison of Field and Laboratory Environments on Asphalt Durability
,” presented at the
Association of Asphalt Paving Technologists
, San Diego, CA, Feb. 16–18,
1981
,
AAPT
,
St. Paul, MN
, pp. 
492
537
.
15.
Edler
,
A. C.
,
Hattingh
,
M. M.
,
Servas
,
V. P.
, and
Marais
,
C. P.
, “
Use of Aging Tests to Determine the Efficacy of Hydrated Lime Additions to Asphalt in Retarding Its Oxidative Hardening
,” presented at the
Association of Asphalt Paving Technologists
, San Antonio, TX, Feb. 11–13,
1985
,
AAPT
,
St. Paul, MN
, pp. 
118
139
.
16.
Wu
,
K.
,
Zhu
,
K.
,
Huang
,
Z. Y.
,
Wang
,
J. C.
,
Yang
,
Q. M.
, and
Liang
,
P.
, “
Research on the Combustion Mechanism of Asphalt and the Composition of Harmful Gas Based on Infrared Spectral Analysis
,”
Spectrosc. Spectral Anal.
, Vol. 
32
, No. 
8
,
2012
, pp. 
2089
2094
, https://doi.org/10.3964/j.issn.1000-0593(2012)08-2089-06
17.
Petersen
,
J. C.
,
A Review of the Fundamentals of Asphalt Oxidation: Chemical, Physicochemical, Physical Property, and Durability Relationships, Transportation Research E-Circular E-C140
,
Transportation Research Board
,
Washington, DC
,
2009
, 78p.
18.
Yang
,
X.
,
You
,
Z.
, and
Mills-Beale
,
J.
, “
Asphalt Binders Blended with a High Percentage of Biobinders: Aging Mechanism Using FTIR and Rheology
,”
J. Mater. Civ. Eng.
, Vol. 
27
, No. 
4
,
2015
, https://doi.org/10.1061/(ASCE)MT.1943-5533.0001117
19.
Read
,
J.
and
Whiteoak
,
D.
,
The Shell Bitumen Handbook
,
Thomas Telford
,
London
,
2003
, 460p.
20.
Bell
,
C. A.
and
Sosnovske
,
D.
,
Ageing: Binder Validation, Report SHRP-A-384
,
Strategic Highway Research Program, National Research Council
,
Washington, DC
,
1994
, 85p.
21.
Saoula
,
S.
,
Soudani
,
K.
,
Haddadi
,
S.
,
Munoz
,
M. E.
, and
Santamaria
,
A.
, “
Analysis of the Rheological Behavior of Aging Bitumen and Predicting the Risk of Permanent Deformation of Asphalt
,”
Mater. Sci. Appl.
, Vol. 
4
,
2013
, pp. 
312
318
, https://doi.org/10.4236/msa.2013.45040
22.
Baek
,
C.
,
Underwood
,
B.
, and
Kim
,
Y.
, “
Effects of Oxidative Aging on Asphalt Mixture Properties
,”
Transp. Res. Rec.
, Vol. 
2296
,
2012
, pp. 
77
85
, https://doi.org/10.3141/2296-08
23.
Airey
,
G. D.
, “
State of the Art Report on Ageing Test Methods for Bituminous Pavement Materials
,”
Int. J. Pavement Eng.
, Vol. 
4
, No. 
3
,
2007
, pp. 
165
176
, https://doi.org/10.1080/1029843042000198568
24.
Griffin
,
R. L.
,
Miles
,
T. K.
, and
Penther
,
C. J.
, “
Microfilm Durability Test for Asphalt
,” presented at the
Association of Asphalt Paving Technologists
,
1955
,
AAPT
,
St. Paul, MN
, pp. 
31
62
.
25.
Montepara
,
A.
and
Giuliani
,
F.
, “
Performance Testing and Specifications for Binder and Mix Comparison between Ageing Simulation Tests of Road Bitumen
,” presented at the
Second Eurasphalt and Eurobitume Congress
, Barcelona, Spain, Sept. 20–22,
2000
,
Foundation Eurasphalt
,
Breukelen, Netherlands
, pp. 
518
523
.
26.
Verhasselt
,
A. F.
, “
The UV/VIS Characterization of Bitumens and Their Generic Fractions
,” presented at the
International Symposium on Chemistry of Bitumens
, Rome, Italy, June 5–8,
1991
,
University of Rome
,
Rome, Italy
, pp. 
79
92
.
27.
Choquet
,
F. S.
, “
The Search for an Ageing Test Based on Changes in the Generic Composition of Bitumens
,” presented at the
International Symposium on Chemistry of Bitumens
, Rome, Italy, June 5–8,
1991
,
University of Rome
,
Rome, Italy
, pp. 
787
812
.
28.
Kai-Fu
,
H.
,
Yu-Chun
,
Z.
,
Ke-Jian
,
L.
,
Peng
,
Y.
,
Feng
,
Y.
, and
Yi
,
W.
, “
A Study on Kinetics of Aging of Paving Asphalt
,”
Pet. Sci. Technol.
, Vol. 
19
, Nos. 
5–6
,
2001
, pp. 
641
650
, https://doi.org/10.1081/LFT-100105279
29.
Siddiqui
,
M. N.
and
Ali
,
M. F.
, “
Studies on the Aging Behavior of the Arabian Asphalts
,”
Fuel
, Vol. 
78
, No. 
9
,
1999
, pp. 
1005
1015
, https://doi.org/10.1016/S0016-2361(99)00018-6
30.
Yan
,
F.
, “
Study on Aging Kinetics of Panjin Paving Asphalt
,”
Pet. Sci. Technol.
, Vol. 
23
, Nos. 
3–4
,
2007
, pp. 
273
283
, https://doi.org/10.1081/LFT-200028291
31.
Ishai
,
I.
, “
A Suggested Methodology for the Analysis of Asphalt Age-Hardening
,”
J. Test. Eval.
, Vol. 
15
, No. 
3
,
1987
, pp. 
127
132
, https://doi.org/10.1520/JTE10997J. ISSN 0090-3973
32.
Lu
,
X.
and
Isacsson
,
U.
, “
Modification of Road Bitumens with Thermoplastic Polymers
,”
Polym. Test.
, Vol. 
20
, No. 
1
,
2000
, pp. 
77
86
, https://doi.org/10.1016/S0142-9418(00)00004-0
33.
Sirin
,
O.
,
Shih
,
C.-T.
,
Tia
,
M.
, and
Ruth
,
B.
, “
Development of a Modified Rotavapor Apparatus and Method for Short-Term Aging of Modified Asphalts
,”
Transp. Res. Rec.
, Vol. 
1638
,
1998
, pp. 
72
81
, https://doi.org/10.3141/1638-09
34.
Salomon
,
D.
and
Zhai
,
H.
, “
Ranking Asphalt Binders by Activation Energy for Flow
,”
J. Appl. Asphalt Binder Technol.
, Vol. 
2
, No. 
2
,
2002
, pp. 
52
60
.
35.
Yan
,
F.
, “
Study on Aging Kinetics of Saudi Arabian Paving Asphalt
,”
Pet. Sci. Technol.
, Vol. 
24
, No. 
7
,
2006
, pp. 
779
788
, https://doi.org/10.1081/LFT-200041082
36.
Jamshidi
,
A.
,
Hamzah
,
M. O.
,
Shahadan
,
Z.
, and
Yahaya
,
A. S.
, “
Evaluation of the Rheological Properties and Activation Energy of Virgin and Recovered Asphalt Binder Blends
,”
J. Mater. Civ. Eng.
, Vol. 
27
, No. 
3
,
2015
, 04014135, https://doi.org/10.1061/(ASCE)MT.1943-5533.0001024
37.
IS 73
Paving Bitumen—Specification (Fourth Revision)
,
Bureau of Indian Standards
,
New Delhi, India
,
2003
.
38.
IS 15462
Polymer and Rubber Modified Bitumen—Specification
,
Bureau of Indian Standards
,
New Delhi, India
,
2004
, http://standards.globalspec.com
39.
AASHTO T 240-13
Standard Method of Test for Effect of Heat and Air on a Moving Film of Asphalt Binder (Rolling Thin-Film Oven Test)
,
American Association of State Highway and Transportation Officials
,
Washington, DC
,
2013
, www.global.ihs.com
40.
AASHTO T 316-13
Standard Method of Test for Viscosity Determination of Asphalt Binder Using Rotational Viscometer
,
American Association of State Highway and Transportation Officials
,
Washington, DC
,
2004
, www.global.ihs.com
41.
Xu
,
O.
,
Cong
,
L.
,
Xiao
,
F.
, and
Amirkhanian
,
S. N.
, “
Rheology Investigation of Combined Binders from Various Polymers with GTR under a Short Term Aging Process
,”
Constr. Build. Mater.
, Vol. 
93
,
2015
, pp. 
1012
1021
, https://doi.org/10.1016/j.conbuildmat.2015.05.051
42.
González
,
V.
,
Martínez-Boza
,
F. J.
,
Navarro
,
F. J.
,
Gallegos
,
C.
,
Pérez-Lepe
,
A.
, and
Páez
,
A.
, “
Thermomechanical Properties of Bitumen Modified with Crumb Tire Rubber and Polymeric Additives
,”
Fuel Process. Technol.
, Vol. 
91
, No. 
9
,
2010
, pp. 
1033
1039
, https://doi.org/10.1016/j.fuproc.2010.03.009
43.
Bahia
,
H. U.
and
Davies
,
R.
, “
Effect of Crumb Rubber Modifiers (CRM) on Performance-Related Properties of Asphalt Binders
,” presented at
Asphalt Paving Technology 1994
, St. Louis, MO, March 21–23,
1994
,
AAPT
,
St. Paul, MN
, pp. 
414
449
.
44.
Heitzman
,
M.
,
Design and Construction of Asphalt Paving Materials with Crumb Rubber Modifier, Publication FHWA-SA-92-022
,
Federal Highway Administration
,
Washington, DC
,
1992
, 132p.
45.
Xiao
,
F.
,
Amirkhanian
,
S. N.
, and
Shen
,
J.
, “
Effects of Various Long-Term Aging Procedures on the Rheological Properties of Laboratory Prepared Rubberized Asphalt Binders
,”
J. Test. Eval.
, Vol. 
37
, No. 
4
,
2009
, pp. 
329
336
, https://doi.org/10.1520/JTE101706
46.
Sun
,
D. Q.
and
Li
,
L. H.
, “
Factors Affecting the Viscosity of Crumb Rubber–Modified Asphalt
,”
Pet. Sci. Technol.
, Vol. 
28
, No. 
15
,
2010
, pp. 
1555
1566
, https://doi.org/10.1080/10916466.2010.497007
47.
Abdelrahman
,
M.
, “
Controlling Performance of Crumb Rubber-Modified Binders through Addition of Polymer Modifiers
,”
Transp. Res. Rec.
, Vol. 
1962
,
2006
, pp. 
64
70
, https://doi.org/10.3141/1962-08
This content is only available via PDF.
You do not currently have access to this content.