Ejection from military aircraft exerts substantial loads on the lumbar spine. Fractures remain common, although the overall survivability of the event has considerably increased over recent decades. The present study was performed to develop and validate a biomechanically accurate experimental model for the high vertical acceleration loading to the lumbar spine that occurs during the catapult phase of aircraft ejection. The model consisted of a vertical drop tower with two horizontal platforms attached to a monorail using low friction linear bearings. A total of four human cadaveric spine specimens (T12-L5) were tested. Each lumbar column was attached to the lower platform through a load cell. Weights were added to the upper platform to match the thorax, head-neck, and upper extremity mass of a 50th percentile male. Both platforms were raised to the drop height and released in unison. Deceleration characteristics of the lower platform were modulated by foam at the bottom of the drop tower. The upper platform applied compressive inertial loads to the top of the specimen during deceleration. All specimens demonstrated complex bending during ejection simulations, with the pattern dependent upon the anterior-posterior location of load application. The model demonstrated adequate inter-specimen kinematic repeatability on a spinal level-by-level basis under different subfailure loading scenarios. One specimen was then exposed to additional tests of increasing acceleration to induce identifiable injury and validate the model as an injury-producing system. Multiple noncontiguous vertebral fractures were obtained at an acceleration of 21 g with 488 g/s rate of onset. This clinically relevant trauma consisted of burst fracture at L1 and wedge fracture at L4. Compression of the vertebral body approached 60% during the failure test, with -6,106 N axial force and 168 Nm flexion moment. Future applications of this model include developing a better understanding of the vertebral injury mechanism during pilot ejection and developing tolerance limits for injuries sustained under a variety of different vertical acceleration scenarios.
Issue Section:
Research Papers
References
1.
Smiley
, J. R.
, 1965, “RCAF Ejection Experience 1952–1961
,” RCAF Institute of Aviation Medicine, Toronto, Ontario, Report No. AD0465171.2.
Smelsey
, S. O.
, 1970, “Study of Pilots Who Have Made Multiple Ejections
,” Aerosp. Med.
, 41
(5
), pp. 563
–566
.3.
Werner
, U.
, 1999, “Ejection Associated Injuries Within the German Air Force From 1981–1997
,” Aviat. Space Environ. Med.
, 70
(12
), pp. 1230
–1234
.4.
Visuri
, T.
, and Aho
, J.
, 1992, “Injuries Associated With the Use of Ejection Seats in Finnish Pilots
,” Aviat. Space Environ. Med.
, 63
(8
), pp. 727
–730
.5.
Rowe
, K. W.
, and Brooks
, C. J.
, 1984, “Head and Neck Injuries in Canadian Forces Ejections
,” Aviat. Space Environ. Med.
, 55
(4
), pp. 313
–315
.6.
Sandstedt
, P.
, 1989, “Experiences of Rocket Seat Ejections in the Swedish Air Force: 1967–1987
,” Aviat. Space Environ. Med.
, 60
(4
), pp. 367
–373
.7.
Newman
, D. G.
, 1995, “The Ejection Experience of the Royal Australian Air Force: 1951–92
,” Aviat. Space Environ. Med.
, 66
(1
), pp. 45
–49
.8.
Harrison
, W. D.
, 1980, “Ejection Experience in F/FB-111 Aircraft-1967–1978
.” Proceedings of the Survival and Flight Equipment Association, Annual Symposium, 17th
, Las Vegas, NV, Dec. 2–6, 1979, Canoga Park, CA, SAFE Association, Creswell, OR, p. 180
–182
.9.
Hearon
, B. F.
, Thomas
, H. A.
, and Raddin
, J. H.
, Jr., 1982, “Mechanism of Vertebral Fracture in the F/FB-111 Ejection Experience
,” Aviat Space Environ Med
, 53
(5
), pp. 440
–448
.10.
Lewis
, M. E.
, 2006, “Survivability and Injuries From Use of Rocket-Assisted Ejection Seats: Analysis of 232 Cases
,” Aviat Space Environ Med
, 77
(9
), pp. 936
–943
.11.
Panjabi
, M. M.
, Oxland
, T. R.
, Kifune
, M.
, Arand
, M.
, Wen
, L.
, and Chen
, A.
, 1995, “Validity of the Three-Column Theory of Thoracolumbar Fractures. A Biomechanic Investigation
,” Spine (Phila Pa 1976)
, 20
(10
), pp. 1122
–1127
.12.
Tran
, N. T.
, Watson
, N. A.
, Tencer
, A. F.
, Ching
, R. P.
, and Anderson
, P. A.
, 1995, “Mechanism of the Burst Fracture in the Thoracolumbar Spine. The Effect of Loading Rate
,” Spine
, 20
(18
), pp. 1984
–1988
.13.
Willen
, J.
, Lindahl
, S.
, Irstam
, L.
, Aldman
, B.
, and Nordwall
, A.
, 1984, “The Thoracolumbar Crush Fracture. An Experimental Study on Instant Axial Dynamic Loading: The Resulting Fracture Type and Its Stability
,” Spine
, 9
(6
), pp. 624
–631
.14.
Cain
, J. E.
, Jr., DeJong
, J. T.
, Dinenberg
, A. S.
, Stefko
, R. M.
, Platenburg
, R. C.
, and Lauerman
, W. C.
, 1993, “Pathomechanical Analysis of Thoracolumbar Burst Fracture Reduction. A Calf Spine Model
,” Spine
, 18
(12
), pp. 1647
–1654
.15.
Cotterill
, P. C.
, Kostuik
, J. P.
, Wilson
, J. A.
, Fernie
, G. R.
, and Maki
, B. E.
, 1987, “Production of a Reproducible Spinal Burst Fracture for Use in Biomechanical Testing
,” J. Orthop. Res.
, 5
(3
), pp. 462
–465
.16.
Fredrickson
, B. E.
, Edwards
, W. T.
, Rauschning
, W.
, Bayley
, J. C.
, and Yuan
, H. A.
, 1992, “Vertebral Burst Fractures: An Experimental, Morphologic, and Radiographic Study
,” Spine
, 17
(9
), pp. 1012
–1021
.17.
Wilcox
, R. K.
, Boerger
, T. O.
, Allen
, D. J.
, Barton
, D. C.
, Limb
, D.
, Dickson
, R. A.
, and Hall
, R. M.
, 2003, “A Dynamic Study of Thoracolumbar Burst Fractures
,” J. Bone Joint Surg. Am.
, 85A
(11
), pp. 2184
–2189
.18.
Duma
, S. M.
, Kemper
, A. R.
, McNeely
, D. M.
, Brolinson
, P. G.
, and Matsuoka
, F.
, 2006, “Biomechanical Response of the Lumbar Spine in Dynamic Compression
,” Biomed. Sci. Instrum.
, 42
, pp. 476
–481
.19.
Hoshikawa
, T.
, Tanaka
, Y.
, Kokubun
, S.
, Lu
, W. W.
, Luk
, K. D.
, and Leong
, J. C.
, 2002, “Flexion-Distraction Injuries in the Thoracolumbar Spine: An In Vitro Study of the Relation Between Flexion Angle and the Motion Axis of Fracture
,” J. Spinal Disord. Tech.
, 15
(2
), pp. 139
–143
.20.
Ochia
, R. S.
, Tencer
, A. F.
, and Ching
, R. P.
, 2003, “Effect of Loading Rate on Endplate and Vertebral Body Strength in Human Lumbar Vertebrae
,” J. Biomech.
, 36
(12
), pp. 1875
–1881
.21.
Shirado
, O.
, Kaneda
, K.
, Tadano
, S.
, Ishikawa
, H.
, McAfee
, P. C.
, and Warden
, K. E.
, 1992, “Influence of Disc Degeneration on Mechanism of Thoracolumbar Burst Fractures
,” Spine
, 17
(3
), pp. 286
–292
.22.
Yoganandan
, N.
, Larson
, S. J.
, Pintar
, F.
, Maiman
, D. J.
, Reinartz
, J.
, and Sances
, A.
, Jr., 1990, “Biomechanics of Lumbar Pedicle Screw/Plate Fixation in Trauma
,” Neurosurgery
, 27
(6
), pp. 873
–880
.23.
Langrana
, N. A.
, Harten
, R. R.
, Lin
, D. C.
, Reiter
, M. F.
, and Lee
, C. K.
, 2002, “Acute Thoracolumbar Burst Fractures: A New View of Loading Mechanisms
,” Spine
, 27
(5
), pp. 498
–508
.24.
Hongo
, M.
, Abe
, E.
, Shimada
, Y.
, Murai
, H.
, Ishikawa
, N.
, and Sato
, K.
, 1999, “Surface Strain Distribution on Thoracic and Lumbar Vertebrae Under Axial Compression. The Role in Burst Fractures
,” Spine
, 24
(12
), pp. 1197
–1202
.25.
Yoganandan
, N.
, Pintar
, F.
, Sances
, A.
, Jr., Myklebust
, J.
, Schmaltz
, D.
, Reinartz
, J.
, Harris
, G.
, Kalbfleisch
, J.
, Chintapalli
, K.
, and Larson
, S.
, 1988, “Steering Wheel Induced Facial Trauma
,” 32nd Stapp Car Crash Conference, Atlanta
, GA, Society of Automotive Engineers, Inc., Warrendale, PA, pp. 45
–69
.26.
Damavandi
, M.
, Farahpour
, N.
, and Allard
, P.
, 2009, “Determination of Body Segment Masses and Centers of Mass Using a Force Plate Method in Individuals of Different Morphology
,” Med. Eng. Phys.
, 31
(9
), pp. 1187
–1194
.27.
Pearsall
, D. J.
, Reid
, J. G.
, and Livingston
, L. A.
, 1996, “Segmental Inertial Parameters of the Human Trunk as Determined From Computed Tomography
,” Ann. Biomed. Eng.
, 24
(2
), pp. 198
–210
.28.
Yoganandan
, N.
, Pintar
, F. A.
, Zhang
, J.
, and Baisden
, J. L.
, 2009, “Physical Properties of the Human Head: Mass, Center of Gravity and Moment of Inertia
,” J. Biomech.
, 42
(9
), pp. 1177
–1192
.29.
Society of Automotive Engineers (SAE), 1995, “
Instrumentation for Impact Test - Part 1
,” Society of Automotive Engineers, Warrendale, PA, Report No. SAE J211/1.30.
Shono
, Y.
, McAfee
, P. C.
, and Cunningham
, B. W.
, 1994, “Experimental Study of Thoracolumbar Burst Fractures. A Radiographic and Biomechanical Analysis of Anterior and Posterior Instrumentation Systems
,” Spine
, 19
(15
), pp. 1711
–1722
.31.
Panjabi
, M. M.
, Oxland
, T. R.
, Lin
, R. M.
, and McGowen
, T. W.
, 1994, “Thoracolumbar Burst Fracture. A Biomechanical Investigation of Its Multidirectional Flexibility
,” Spine
, 19
(5
), pp. 578
–585
.32.
Panjabi
, M. M.
, Kifune
, M.
, Liu
, W.
, Arand
, M.
, Vasavada
, A.
, and Oxland
, T. R.
, 1998, “Graded Thoracolumbar Spinal Injuries: Development of Multidirectional Instability
,” Eur. Spine J.
, 7
(4
), pp. 332
–339
.33.
Adams
, M. A.
, and Hutton
, W. C.
, 1983, “The Effect of Posture on the Fluid Content of Lumbar Intervertebral Discs
,” Spine
, 8
(6
), pp. 665
–671
.34.
Brinckmann
, P.
, Frobin
, W.
, Hierholzer
, E.
, and Horst
, M.
, 1983, “Deformation of the Vertebral End-Plate Under Axial Loading of the Spine
,” Spine
, 8
(8
), pp. 851
–856
.35.
Brown
, S. H.
, Gregory
, D. E.
, and McGill
, S. M.
, 2008, “Vertebral End-Plate Fractures as a Result of High Rate Pressure Loading in the Nucleus of the Young Adult Porcine Spine
,” J. Biomech.
, 41
(1
), pp. 122
–127
.36.
Gunning
, J. L.
, Callaghan
, J. P.
, and McGill
, S. M.
, 2001, “Spinal Posture and Prior Loading History Modulate Compressive Strength and Type of Failure in the Spine: A Biomechanical Study Using a Porcine Cervical Spine Model
,” Clin. Biomech.
, 16
(6
), pp. 471
–480
.37.
Parkinson
, R. J.
, and Callaghan
, J. P.
, 2009, “The Role of Dynamic Flexion in Spine Injury is Altered by Increasing Dynamic Load Magnitude
,” Clin. Biomech.
, 24
(2
), pp. 148
–154
.38.
Nakamura
, A.
, 2007, “Ejection Experience 1956–2004 in Japan: An Epidemiological Study
,” Aviat. Space Environ. Med.
, 78
(1
), pp. 54
–58
.39.
Moreno Vazquez
, J. M.
, Duran Tejeda
, M. R.
, and Garcia Alcon
, J. L.
, 1999, “Report of Ejections in the Spanish Air Force, 1979–1995: An Epidemiological and Comparative Study
,” Aviat. Space Environ. Med.
, 70
(7
), pp. 686
–691
.40.
Sturgeon
, W. R.
, 1988, “Canadian Forces Aircrew Ejection, Descent, and Landing Injuries: 1 January 1975–31 December (1987)
,” Defense and Civil Institute of Environmental Medicine, Downsview, Ontario, Report No. DCIEM No. 88-RRR-56.41.
Milanov
, L.
, 1996, “Aircrew Ejections in the Republic of Bulgaria, 1953–93
,” Aviat. Space Environ. Med.
, 67
(4
), pp. 364
–368
.42.
Shanahan
, D. F.
, and Shanahan
, M. O.
, 1989, “Injury in U.S. Army Helicopter Crashes October 1979–September (1985)
,” J. Trauma
, 29
(4
), pp. 415
–423
.43.
Richter
, D.
, Hahn
, M. P.
, Ostermann
, P. A.
, Ekkernkamp
, A.
, and Muhr
, G.
, 1996, “Vertical Deceleration Injuries: A Comparative Study of the Injury Patterns of 101 Patients After Accidental and Intentional High Falls
,” Injury
, 27
(9
), pp. 655
–659
.44.
Hsu
, J. M.
, Joseph
, T.
, and Ellis
, A. M.
, 2003, “Thoracolumbar Fracture in Blunt Trauma Patients: Guidelines for Diagnosis and Imaging
,” Injury
, 34
(6
), pp. 426
–433
.45.
Inamasu
, J.
, and Guiot
, B. H.
, 2007, “Thoracolumbar Junction Injuries After Motor Vehicle Collision: Are There Differences in Restrained and Nonrestrained Front Seat Occupants?
,” J. Neurosurg. Spine
, 7
(3
), pp. 311
–314
.46.
Ragel
, B. T.
, Allred
, C. D.
, Brevard
, S.
, Davis
, R. T.
, and Frank
, E. H.
, 2009, “Fractures of the Thoracolumbar Spine Sustained by Soldiers in Vehicles Attacked by Improvised Explosive Devices
,” Spine
, 34
(22
), pp. 2400
–2405
.47.
Denis
, F.
, 1983, “The Three Column Spine and Its Significance in the Classification of Acute Thoracolumbar Spinal Injuries
,” Spine
, 8
(8
), pp. 817
–831
.48.
Lin
, R. M.
, Panjabi
, M. M.
, and Oxland
, T. R.
, 1993, “Functional Radiographs of Acute Thoracolumbar Burst Fractures. A Biomechanical Study
,” Spine
, 18
(16
), pp. 2431
–2437
.49.
Kifune
, M.
, Panjabi
, M. M.
, Arand
, M.
, and Liu
, W.
, 1995, “Fracture Pattern and Instability of Thoracolumbar Injuries
,” Eur. Spine J.
, 4
(2
), pp. 98
–103
.50.
Demetropoulos
, C. K.
, Yang
, K. H.
, Grimm
, M. J.
, Artham
, K. K.
, and King
, A. I.
, 1999, “High Rate Mechanical Properties of the Hybrid III and Cadaveric Lumbar Spines in Flexion and Extension
,” 43rd Stapp Car Crash Conference
, San Diego, CA, Society of Automotive Engineers, Inc., Warrendale, PA, pp. 279
–294
.51.
Panjabi
, M. M.
, Crisco
, J. J.
, Vasavada
, A.
, Oda
, T.
, Cholewicki
, J.
, Nibu
, K.
, and Shin
, E.
, 2001, “Mechanical Properties of the Human Cervical Spine as Shown by Three-Dimensional Load-Displacement Curves
,” Spine
, 26
(24
), pp. 2692
–2700
.52.
Dickey
, J. P.
, and Kerr
, D. J.
, 2003, “Effect of Specimen Length: Are the Mechanics of Individual Motion Segments Comparable in Functional Spinal Units and Multisegment Specimens?
,” Med. Eng. Phys.
, 25
(3
), pp. 221
–227
.53.
Bernstein
, M.
, 2010, “Easily Missed Thoracolumbar Spine Fractures
,” Eur. J Radiol.
, 74
(1
), pp. 6
–15
.54.
Panjabi
, M. M.
, Hoffman
, H.
, Kato
, Y.
, and Cholewicki
, J.
, 2000, “Superiority of Incremental Trauma Approach in Experimental Burst Fracture Studies
,” Clin. Biomech.
, 15
(2
), pp. 73
–78
.55.
Mermelstein
, L. E.
, McLain
, R. F.
, and Yerby
, S. A.
, 1998, “Reinforcement of Thoracolumbar Burst Fractures With Calcium Phosphate Cement. A Biomechanical Study
,” Spine
, 23
(6
), pp. 664
–670
.56.
Yoganandan
, N.
, Pintar
, F. A.
, Sances
, A.
, Jr., Maiman
, D. J.
, Myklebust
, J.
, Harris
, G.
, and Ray
, G.
, 1989, “Biomechanical Investigations of the Human Thoracolumbar Spine
,” SAE Trans.
, 97
(5
), pp. 676
–681
.Copyright © 2011
by American Society of Mechanical Engineers
You do not currently have access to this content.
