An experimental study has been performed on single-phase heat transfer of de-ionized water over a bank of shrouded micro pin fins 243-μm long with hydraulic diameter of 99.5-μm. Heat transfer coefficients and Nusselt numbers have been obtained over effective heat fluxes ranging from 3.8 to 167 W/cm2 and Reynolds numbers from 14 to 112. The results were used to derive the Nusselt numbers and total thermal resistances. It has been found that endwalls effects are significant at low Reynolds numbers and diminish at higher Reynolds numbers.

1.
Hitt
D. L.
,
Zakrzwski
C. M.
, and
Thomas
M. A.
,
MEMS-based satellite micropropulsion via catalyzed hydrogen peroxide decomposition
,
Smart Materials and Structures
10
(
2001
)
1163
1175
.
2.
London
A. P.
,
Ayon
A. A.
,
Epstein
A. E.
,
Spearing
S. M.
,
Harrison
T.
,
Peles
Y.
, and
Kerrebrock
J. L.
,
Microfabrication of a High Pressure Bipropellant Rocket Engine
,
Sensors and Actuators A: Physical
92
(
1–3
) (
2001
)
351
357
.
3.
Spadaccini
C. M.
,
Zhang
X.
,
Cadou
C. P.
,
Miki
N.
, and
Waitz
I. A.
,
Preliminary development of a hydrocarbon-fueled catalytic micro-combustor
,
Sensors and Actuators, A: Physical
103
(
1–2
)(
2003
)
219
224
.
4.
Lee
D. H.
and
Kwon
S.
,
Heat transfer and quenching analysis of combustion in a micro combustion vessel
,
Journal of Micromechanics and Microengineering
12
(
5
) (
2002
)
670
676
.
5.
Peles
Y.
,
Kos¸ar
A.
,
Mishra
C.
,
Kuo
C.-J.
, and
Schneider
B.
, “
Forced Convective Heat Transfer Across a Pin Fin Micro Heat Exchanger
,”
International Journal of Heat and Mass Transfer
,
48
(
17
), pp.
3615
3627
,
2005
.
6.
Jiang
L.
,
Wong
M.
, and
Zohar
Y.
,
2001
, “
Forced Convection Boiling in Microchannel Heat Sink
,”
Journal of Microelectromechanical Systems
,
10
(
1
), pp.
80
87
.
7.
Wu
H. Y.
and
Cheng
P.
,
2003
, “
Visualization and Measurements of Periodic Boiling in Silicon Microchannels
,”
International Journal of Heat and Mass Transfer
,
46
(
14
), pp.
2603
2614
.
8.
Koo
J.-M.
,
Im
S.
,
Jiang
L.
, and
Goodson
K. E.
2005
, “
Integrated Microchannel Cooling for Three-dimensional Electronic Circuit Architectures
,”
Journal of Heat Transfer
,
127
(
1
), pp.
49
58
.
9.
Zhang
L.
,
Wang
E. N.
,
Goodson
K. E.
, and
Kenny
T. W.
,
2005
, “
Phase Change Phenomena in Silicon Microchannels
,”
International Journal of Heat and Mass Transfer
40
(
8
), pp.
1572
1582
.
10.
Kos¸ar, A., Kuo, C.J., and Peles, Y., “Boiling Heat Transfer in Rectangular Microchannels with Reentrant Cavities,” International Journal of Heat and Mass Transfer, in press (2005).
11.
Arana
L. R.
,
Schaevitz
S. B.
,
Franz
A. J.
,
Schmidt
M. A.
, and
Jensen
K. F.
,
Microfabricated suspended-tube chemical reactor for thermally efficient fuel processing
,
Journal of Microelectromechanical Systems
12
(
5
) (
2003
)
600
612
.
12.
Losey
M. W.
,
Jackman
J.
,
Firebaugh
S. I.
,
Schmidt
M. A.
, and
Jensen
K. F.
,
Design and Fabrication of Microfluidic Devices for Multiphase Mixing and Reaction
,
Journal of Microelectromechanical Systems
11
(
6
) (
2002
)
709
717
.
13.
Epstein
A. H.
and
Senturia
S. D.
,
Macro power from micro machinery
,
Science
276
(
5316
) (
1997
)
1211
1211
.
14.
London, A.P., Ph.D. Thesis, Development and test of a microfabricated bipropellant rocket engine, Cambridge, MA, USA, 2000.
15.
Sparrow
E. M.
,
Abraham
J. P.
, and
Tong
J. C. K.
,
2004
, “
Archival correlations for average heat transfer coefficients for non-circular and circular cylinders and for spheres in cross-flow
,”
International Journal of Heat and Mass Transfer
,
47
(
24
), pp.
5285
5296
.
16.
Zukauskas
A. A.
,
1972
, “
Heat Transfer from Tubes in Cross Flow
,”
Advances in Heat Transfer
,
8
, Academic Press, New York, pp.
93
160
.
17.
Whitaker
S.
,
1972
, “
Forced Convection Heat-Transfer Correlations for Flow in Pipes, Past Flat Plates, Single Cylinders, Single Spheres, and For Flow in Packed-Beds and Tube Bundles
,”
AIChE Journal
,
18
(
2
), p.
361
371
.
18.
Igarashi
T.
,
1987
, “
Fluid Flow and Heat Transfer around Rectangular Cylinders (the Case of a Width/Height Ratio of a Section of 0.33–1.5)
,”
International Journal of Heat and Mass Transfer
,
30
, pp.
893
901
.
19.
Chyu
M. K.
,
Hsing
Y. C.
, and
Natarajan
V.
,
1998
, “
Convective Heat Transier of Cubic Fin Arrays in a Narrow Channel
,”
Journal of Heat Transfer
,
120
, pp.
362
367
.
20.
Merker
G. P.
and
Hanke
H.
,
1986
, “
Heat Transfer and Pressure Drop on the Shell-Side of Tube-Banks Having Oval-Shaped Tubes
,”
International Journal of Heat and Mass Transfer
,
29
(
12
), pp.
1903
1909
.
21.
Reiher
H.
,
1925
, “
Der Wa¨rmeu¨bergang von Stro¨mender Luft an Rohrbu¨ndel in Kreuzstrom
,”
VDI Forschungsheft
,
269
, pp.
47
47
.
22.
Sparrow
E. M.
and
Grannis
V. B.
,
1991
, “
Pressure Drop Characteristics of Heat Exchangers Consisting of Arrays of Diamond-Shaped Pin Fins
,”
International Journal of Heat and Mass Transfer
,
34
(
3
), pp.
589
600
.
23.
Hilpert
R.
,
1933
, “
Der Wa¨rmeabgabe von Geheizten Drahten und Rohren im Luftstorm
,”
Forsch. Geb Ingenieurwes
,
4
, pp.
215
224
.
24.
Ruth
E. K.
,
1983
, “
Experiments on a Cross Flow Heat Exchanger with Tubes of Lenticular Shape
,”
Journal of Heat Transfer
,
105
, pp.
571
575
.
25.
Armstrong
J.
and
Winstanley
D.
,
1988
, “
A Review of Staggered Array Pin Fin Heat Transfer for Turbine Cooling Applications
,”
ASME Journal of Turbomachinery
,
110
, pp.
94
103
.
26.
Sparrow
H. M.
,
Stahl
T. J.
, and
Traub
P.
,
1984
, “
Heat Transfer Adjacent to the Attached End of a Cylinder in Crossflow
,”
International Journal of Heat and Mass Transfer
,
27
, pp.
233
242
.
27.
Damerow, W.P., Murtaugh, J.C, and Burgraf, F., 1972, “Experimental and Analytical Investigation of the Coolant Flow Characteristics in Cooled Turbine Airfoils,” NASA, CR-120883.
28.
Metzger
D. E.
,
Fan
Z. N.
, and
Shepard
W. B.
,
1982
b, “
Pressure Loss and Heat Transfer Through Multiple Rows of Short Pin Fins
,”
Journal of Heat Transfer
,
3
, U. Grigull et al., eds., Hemisphere, Washington, pp.
137
142
.
29.
Short
B. E.
,
Raad
P. M.
, and
Price
D. C.
,
2002
, “
Performance of Pin Fin Cast Aluminum Coldwalls, Part.2: Colburn j-Factor Correlations
,”
Journal of Thermophysics and Heat Transfer
,
16
(
3
), pp.
397
403
.
30.
Kline
S.
and
McClintock
F. A.
,
1953
, “
Describing Uncertainties in Single-Sample Experiments
,”
Mechanical Engineering
,
75
(
1
), pp.
3
8
.
31.
Incropera, F.P. and DeWitt, D.P, Introduction to Heat Transfer, Fourth ed., Wiley, New York, 2002, pp. 396.
32.
Panton, R., Incompressible Flow, Second ed., Wiley, New York, 1996, pp. 384–400.
33.
Cengel, Y.A. and Turner, R.H., 2001, Fundamentals of Thermal-Fluids Sciences. McGraw Hill, Boston, pp. 575–577.
34.
Shair
F. H.
,
Grove
A. S.
,
Petersen
E. E.
, and
Acrivos
A.
,
1963
, “
The Effect of Confining Walls on the Stability of the Steady Wake Behind a Circular Cylinder
,”
Journal of Fluid Mechanics
,
17
, pp.
546
550
.
35.
Nishioka
M.
and
Sato
H.
,
1973
, “
Measurements of Velocity Distributions in the Wake of a Circular Cylinder at Low Reynolds Number
,”
Journal of Fluid Mechanics
,
65
, pp.
97
112
.
This content is only available via PDF.
You do not currently have access to this content.